地面石材工程質量施工方案.doc

yuan, an increase of 17.5%; local government general budget revenue of 500 million Yuan, . Painting, model culture creates new Ma Church community, creating Lake scenic spot culture education base, received high evaluation from provincial and municipal discipline Inspection Commission, the peoples daily special report. Constantly promote independent Commission against corruption culture construction to rural extends, created established Dahlin rural industry Park independent Commission against corruption culture positions, formed has a support service low double excellent of members lead team, constantly perfect and established Park funds assets management, and village audit supervision, and villagers democratic financial, system, strengthening Park party, and Chief, and financial, full public, powerful to guarantees has new rural construction, by city rural style clean government inspection unit led of height evaluation. Through the implementation of honest and clean government cultural construction, and effectively educate the broad masses of party members and cadres and consciously regulated behavior and discipline, honesty in politics and culture to create a good atmosphere and fresh development environment. Although we in implement implementation independent Commission against corruption guidelines aspects made has must effectiveness, but away from superior of requirements also exists must of distance, main performance for: a is system enough sound, education, and supervision, and prevention, and punishment, aspects long-term mechanism also enough perfect, especially in enrollment bid work regulatory aspects also needed strengthening; II is regulatory supervision exists lost of Yu wide, and lost of Yu soft, investigation illegal disciplinary case of efforts also needed strengthening, individual sector and cadres also different degree exists treat gift, not to benefits not do, and mess do of phenomenon; Three for honest work is the new situations and new problems in finding timely enough, treatment measures are not strong enough. To solve these problems, we will proceed from the following five aspects of rectification, make sure to implement the provisions of the code. (A) deepening the learning, enhance the consciousness of honesty in politics. To create event as an opportunity to Excel and learning party, further increasing the governance capability and advanced construction, reinforced rules of the broad masses of party members and cadres awareness, sense of responsibility, sense of honor, improve working ability and level of scientific development. Should make full use of meetings, in particular central group learning opportunity, further strengthening the study and education of the code, the intensive warning education, education the majority of party members and cadres known fear, knew fear, honesty in politics of tension the strings, consciousness and enhancing the implementation of the initiative. Also, pay attention to apply what they have learned, consciously study results into planning work, new ideas,中鐵一局集團建筑安裝工程有限公司昆明軌道交通首期北段車站設備安裝及裝修五標 昆明軌道交通首期北段車站設備安裝及裝修五標防靜電活動地板鋪貼施工方案編制人： 審核人： 批準人： 批 準 部 門（章）： 編 制 日 期： 昆明軌道交通首期北段車站設備安裝及裝修五標防靜電架空地板鋪貼施工方案1 范圍本工藝標準適用于有防塵和導靜電要求的民用、公共建筑等專業用房地面。依據標準：建筑工程施工質量驗收統一標準GB50300-2001建筑地面工程施工質量驗收規范GB50209-20022 施工準備 2.1 材料要求： 2.1.1 活動地板面層應包括標準地板、異形地板和地板附件（即支架和橫梁組件），其規格、型號應由設計確定，采購配套系列合格產品。2.1.2 活動地板應以特制的平壓刨花板為基材，表面飾以裝飾板和底層用鍍鋅鋼板經粘結膠合組成的板塊，應平整、堅實、并具有耐磨、防潮、阻燃、耐污染，耐老化和導靜電特點，其技術性能與技術指標應符合現行的有關產品標準的規定。2.1.3 環氧樹脂膠、滑石粉、泡沫塑料條、木條、橡膠條。鋁型材和角鐵、鋁型角鐵等材質，要符合要求。2.2 作業條件：2.2.1在鋪設活動地板面層時，應待室內各項工程完工和超過地板承載力的設備進入房間預定位置以及相鄰房間內部也全部完工后，方可進行，不得交叉施工。2.2.2鋪設活動地板面層的基層已做完，一般是水泥地面或現制水磨石地面等。2.2.3墻面+50cm水平標高線已彈好，門框已安裝完。并在四周墻面上彈出面層標高水平控制線。2.2.4大面積施工前，應先放出施工大樣，并做樣板間，經各有關部門鑒定合格后，再繼續以此為樣板進行操作。2.3 主要機具：水平儀、鐵制水平尺、鐵制方尺、23m靠尺板、墨斗（或粉線包）、小線、線墜、笤帚、盒尺、鋼尺、釘子、鐵絲、紅鉛筆、油刷、開刀、吸盤、手推車、鐵簸箕、小鐵錘、合金鋼扁鏨子、裁改板面用的圓盤鋸、無齒鋸、木工用截料鋸、刀鋸、手刨、斧子、磅秤、鋼絲鉗子、小水桶、棉絲、小方鍬、螺絲扳手。3 操作工藝3.1 工藝流程：基層處理找中、套方、分格、彈線安裝支座和橫梁組件、鋪設地板面層清擦和打蠟3.2基層處理3.2.1 活動地板面層的金屬支架應支承在現澆混凝土基層上或規制水磨石地面上，基層表面應平整、光潔、不起灰。含水率不大于8%。安裝前應認真清擦干凈，必要時根據設計要求，在基層表面上涂刷絕緣漆。絕緣漆必須清潔、干燥、平整、無劃痕、無雜物。 3.3 找中、套方、分格、彈線 3.3.1 首先量測房間的長、寬尺寸，找出縱橫線中心交點。當房間是矩形時，用方尺量測相鄰的墻體是否垂直，如互相不垂直，應預先對墻面進行處理，避免在安裝活動板塊時，在靠墻處出現棋形板塊。根據已量測好的平面長、寬尺寸進行計算，如果不符合活動板板塊模數時，依據已找好的縱橫中線交點，進行對稱分格，考慮將非整塊板放在室內靠墻處，在基層表面上就按板塊尺寸彈線并形成方格網，標出地板塊安裝位置和高度（標在四周墻上），并標明設備預留部位。此項工作必須認真細致，做到方格控制線尺寸準確（此時應插入鋪設活動地板下的管線，操作時要注意避開已彈好支架底座的位置）。 3.4安裝支座和橫梁組件3.4.1 檢查復核已彈在四周墻上的標高控制線，確定安裝基準點，然后按基層面上已彈好的方格網交點處安放支座和橫梁，并應轉動支座螺桿，先用小線和水平尺調整支座面高度至全室等高，待所有支座柱和橫梁構成一體后，應用水平儀抄平。支座與基層面之間的空隙應灌注環氧樹脂，應連接牢固。亦可根據設計要求用膨脹螺栓或射釘連接。架空地板下沿墻角四周安裝接地干線(母線) 材質為鍍鋅扁鋼（254mm）上；每隔兩塊從支撐或橫梁接一根接地支線(黃綠銅芯絞線1X25mm2)接至干線鍍鋅扁鋼上；地干線接到各弱電機房接地端子箱上的預留接地端子上。3.5鋪設活動地板面層3.5.1根據房間平面尺寸和設備等情況，應按活動地板模數選擇板塊的鋪設方向。當平面尺寸符合活動地板板塊模數，而室內無控制柜設備時，宜由里向外鋪設，當平面尺寸不符合活動地板板塊模數時，宜由外向里鋪設。當室內有控制柜設備且需要預留洞口時，鋪設方向和先后順序應綜合考慮選定。鋪設前活動地板面層下鋪設的電纜、管線已經過檢查驗收，并辦完隱蔽檢查驗收手續。先在橫梁上鋪設緩沖膠條，并用乳膠液與橫梁粘合。鋪設活動地板塊時，應調整水平度，保證四角接觸處平整、嚴密，不得采用加墊的方法。鋪設活動地板塊不符合模數時，不足部分可根據實際尺寸將板面切割后鑲補，并配裝相應的可調支撐和橫梁。切割的邊應采用清漆或環氧樹脂膠加滑石粉按比例調成膩?zhàn)臃膺叄蛴梅莱蹦佔臃膺?，也可采用鋁型材鑲嵌。在與墻邊的接縫處，應根據接縫寬窄分別采用活動地板或木條刷高強膠鑲嵌，窄縫宜用泡沫塑料鑲嵌。隨后立即檢查調整板塊水平度及縫隙?；顒?dòng)地板面層鋪先后，面層承載力不應小于7.5MPa，其體積電阻率值105109。3.6清擦和打蠟3.6.1當活動地板面層全部完成，經檢查平整度及縫隙均符合質量要求后，即可進行清擦。當局部沾污時，可用清潔劑或皂水用布擦凈晾干后，用棉絲抹蠟，滿擦一遍，然后將門封閉。如果還有其他專業工序操作時，在打蠟前先用塑料布滿鋪后，再用3mm以上的橡膠板蓋上，等其全部工序完成后，再清擦打蠟交活。4 質量標準4.1保證項目4.1.1活動地板的品種、規格和技術性能必須符合設計要求。施工規范和現行國家標準的規定。4.2基本項目4.2.1表面潔凈，圖案清晰，色澤一致，接縫均勻，周邊順直，板塊無裂紋、掉角和缺楞等現象。各種面層鄰接處的鑲邊用料及尺寸符合設計要求和施工規范的規定，邊角整齊，光滑。4.3活動地板允許偏差項目下表?；顒?dòng)地板允許偏差表項次項 目允許偏差 (mm)檢驗方法1表面平整2用2m靠托線板和楔形塞尺檢查2縫格平直3拉5m小線檢查 (不足5m拉通線) 尺量3接縫高低差0.4用鋼板短尺和楔形塞尺檢查4板塊間隙寬度不大于0.3用楔形塞尺檢查5 成品保護5.1操作過程中注意保護好已完成的各分項分部工程成品的質量。在運輸和施工操作中，要保護好門窗框扇，特別是鋁合金門窗框扇和玻璃、墻紙、踢腳板等。5.2活動地板等配套系列材料進場后，應設專人負責檢查驗收其規格、數量、并做好保管工作，尤其在運輸、裝卸、堆放過程中，要注意保護好面板，不要碰壞面層和邊角。5.3在安裝過程中要注意對面層的保護，堅持隨污染隨清擦，特別是環氧樹脂和乳膠液體，應及時擦干凈。5.4在已鋪好的面板上行走或作業，應穿泡沫塑料拖鞋或軟底鞋，不能穿帶有金屬釘?shù)男８荒苡娩J器、硬物在面板上拖拉、劃擦及敲擊。5.5在面板安裝后，再安裝設備時，應注意采取保護面板的臨時性保護措施，一般在鋪設3mm厚以上的橡膠板上墊膠合板。5.6安裝設備時應根據設備的支承和荷重情況，確定地板支承系統的加固措施。6 應注意的質量問題6.1活動地板及其配套支承系列的材質和技術性能要符合設計要求，并有出廠合格證，在面積施工操作前，要進行試鋪工作。6.2彈完方格網實線后，要及時插入鋪設活動地板下的電纜管線的工序，并經驗收合格后再安支承系統，這樣做既避免了不應有的返工，同時又保證支架不被碰撞造成松動。6.3安裝底座時，要檢查是否對準方格網中心交點，待橫梁全部安裝完后要拉橫豎線，檢查橫梁的平直度，以保證面板安裝后縫格的平直度控制在3mm之內，面板安裝之后隨時拉小線再次進行檢查。橫梁的頂標高也要嚴格控制，用水平儀核對整個橫梁的上平。7 質量記錄明7.1活動面板的技術性能與技術指標的出廠合格證。7.2金屬支架配套體系的出廠證。8 安全環保措施8.1在運輸、堆放、施工過程中應注意避免揚塵、遺撒、沾帶等現象，應采取遮蓋、封閉、灑水、沖洗等必要措施。8.2運輸、施工所用車輛、機械的廢氣、噪聲等應符合環保要求。8.3電氣裝置應符合施工用電安全管理規定。采用的原料均來源于草本植物，并不包含任何人工合成添加劑。以健康養生為理念，以天然植物為原料，更加符合現代人的生活訴求，已經成為消費者日常飲料的主要選擇。new measures to promote work, the courage to take responsibility, dare to break hard to ensure district, Government decisions and arrangements to implement. (B) strengthening supervision, severely punish acts of violation. One is to open the channels of supervision. Vigorously promote the party affairs public, open, widely accepted supervision by the masses, pay attention to social groups and public opinion supervision, the powerful force formed to urge party members and leading cadres properly exercise their powers. Second, strong supervision and inspection. Democratic life into full play, important briefings, reports related to personal matters and evaluation of cadres study of inner-party supervisory system, a comprehensive grasp of guidelines for the implementation of the independent Commission against corruption-related cases of leading cadres of party members, focus on strengthening key areas of project selection, funding, officials monitor, detect and rectify the problem, promote honesty in politics. Third, strengthen disciplinary investigation. Seriously the implementation of JI .Recently, the County leading bodies at the county level to carry out three trees practice, which is to improve the governing ability and promoting the development of XX effective measure. I carefully follow your deployment requirements, and actively participate in the three trees campaign. Read Group, prepared by the Department in the near future of the ideological and political construction of leading cadres in the city reader, read the relevant information, larger harvest, inspired. I think the ability of repelling is to strengthen the partys governing capacity in questions of the construction of meaning, an important topic remains in front of party members and cadres at all levels, we need to further explore and ponder. The ability of repelling the name suggests, is asking party members and cadres at all levels in particular, leading cadres at all levels, not only ourselves, establish a correct concept of the independent Commission against corruption, political integrity, self-discipline, rejection of corru