4000噸每天水泥回轉窯煙氣除塵工程設計1

1、4000噸每天水泥回轉窯煙氣除塵工程設計本科畢業設計（論文）4000t/d水泥回轉窯煙氣除塵工程設計學 院 環境科學與工程學院 專 業 環 境 工 程 年級班別 20xx級（x）班 學 號 310x008xxx 學生姓名 xxx 指導教師 xx 20xx年 x 月設計總說明設計任務由來：為了控制水泥工業的大氣污染物排放，促進水泥工業產業結構調整，國家環境保護總局組織中國環境科學研究院、合肥水泥研究設計院、中國材料工業科工集團公司起草了新的水泥工業大氣污染物排放標準（gb4915-2004）。水泥回轉窯窯尾是水泥生產環節中粉塵排放量最大的排放點，窯外分解窯尾煙塵濃度為60g/m380g/m3，這

2、一環節的污染物成分復雜，除粉塵、煙塵外，還有二氧化硫、氮氧化物、氟化物等有害氣體水泥產量：4000噸/天；煙氣溫度：45200；煙氣含塵濃度：500030000mg/nm3；煙氣濕度：515。設計原則：設計中要認真貫徹國家的經濟建設方針、政策。應充分考慮資源的充分利用。選用的技術要先進適用。工程設計要堅持安全可靠、質量第一的原則。堅持經濟合理原則必須遵循國家有關環境保護法律、法規，合理開發和充分利用各種自然 資源，嚴格控制環境污染，保護和改善生態環境建設項目需要配套建設的環境保護設施，必須與主體工程同時設計、同時施工、同時投產使用。 必須遵守污染物排放的國家標準和地方標準。應當在建設項目中采用

3、能耗物耗小、污染物產生量少的清潔生產工藝。關鍵詞：水泥回轉窯，煙氣，除塵specificationin order to control the cement industry the air pollutant emissions, the promotion cement industry industrial structure adjustment, country environmental protection bureau organized china environmental science research institute, hefei cement research

4、 design institute, chinese material industry science and industry group company to draft newly cement industry air pollutant emissions standard gb4915-2004 .the cement rotary kiln kiln tail is in the cement production link the dust withdrawal biggest emission point, outside the kiln decomposes the k

5、iln tail mist and dust density is 60g/m380g/m3, this link pollutant ingredient is complex, except outside dust, mist and dust, but also has the sulphur dioxide, the nitrogen oxide compound, the fluoride and so on the noxious gas, but the dust is most serious to the air pollution.design standardexist

6、ing production line craft, operating mode and related technical data, document materialguangdong province air pollutant emissions limiting value db44/27-2001 industrial enterprise designs hygienic standard tj36-79 cement industry pollutant emissions standard gb4915-85 the rotary kiln related technic

7、al parameter is as follows:cement output: 4000 tons/days;haze temperature: 45400;the haze contains the dust density: 500030000mg/nm3; haze humidity: 10%20%design philosophy1 in the design must implement national earnestly the principles of national economy, the policy.2 should consider the resources

8、 fully the full use.3 selects the technology must be suitable advanced.4 the engineering design needs to persist safely reliable, the quality first principle.5 persists the economical reasonable principle6 must follow the country related environmental protection law, the laws and regulations, the re

9、asonable development and uses each natural resource fully,strict control environmental pollution, protection and improvement ecological environment7 the items of basic construction need to form a complete set the construction environmental protection facility, must simultaneously design with the pri

10、ncipal part of a project, simultaneously construct, simultaneously goes into production the use.8 must observe the pollutant emissions the national standards and the place standard.9 must use the energy consumption material and energy consumption slightly in the items of basic construction, the poll

11、utant has the quantity few clean production craft.key word: cement rotary kiln, haze, dust removal目錄1 概述11.1 水泥工業污染及特征11.2 水泥廠回轉窯粉塵污染治理11.3 水泥廠基本情況52 水泥廠回轉窯除塵設備的選擇62.1 水泥廠回轉窯粉塵特點及煙氣條件62.2 除塵器選用60. 除塵器的選擇要點6. 除塵器的選用原則7. 除塵器的選擇83 脈沖布袋除塵器的選型計算和設計113.1設計依據11.據標準11.容113.2 脈沖布袋除塵器的選型計算12. 除塵系統初步設計方案12. 脈沖布袋除塵器相關技術及參數選擇13.藝流程設計14.備能力計算154 脈沖布袋除塵器的保溫與防腐195 脈沖布袋除塵器的安裝、調試、維護和檢修2