2017年7月風機運行分析報告報告材料

wordwordPAGEPAGE1/1620177〔20170626-20170725〔蘇揚〕一、概述232MWFD116A46MW20170625245405.288kWh。462MWFD116A92MW20170625245275.268kWh。二、單機發電量分析A205、#25、#26、#27#28。發電量B20155#19#21#22、#23。發電量C153623#45#6#21、#22、#23；二期：#3、#4、#5、#6、#7、#8、#9、#10、#11、#12、#39、#40、#41、#42、#43、#44、#45、#46、#47、#48、#49、#50、#29、#30、#31、#32、#33、#34、#35、#14、#16、#17、#20、#36、#37、#38。#24-#230123.1301萬#17-#1309萬kWh；發電小時數最高#18-#2405風機h，發電小時數最低#17-#1309h#47-#22093.85m/s#06-#21062.12m/s。根據本月風機產能報表〔具體數據見附件〕可知，大面山一期風機單機發電量8.4026萬度，去除15#-19#風機大面山一期風機單機發電量9.18564612.2557145.85%，為去除15#-19133.42%。三、風機損失電量分析風機故障損失電量統計表日期風機編號原因故障停機時間〔時〕故障處理損失電量kWh)2017/6/2732-2309安全鏈緊停9.100.9502017/6/2822-2409偏航電機加熱器故障0.000.00損失占發電2017/6/2904-1101變槳安全鏈斷開6.558.63〔％〕2017/6/295-1102變槳安全鏈斷開0.272.572017/6/2925-2302變槳安全鏈斷開8.820.002017/6/3020-1310槳葉2電機和編碼器讀數偏差大6.201.232017/7/125-2302變槳安全鏈斷開1.683.7202017/7/1239-2201安全鏈緊停15.080.9002017/7/1431-2308低速軸前軸承溫度高報警1.022.8002017/7/1408-2108變頻器故障2.852.2702017/7/1520-1310軸柜124V電源供電故障2.281.8502017/7/1511-1107變頻器故障1.271.9802017/7/1520-1310軸柜124V電源故障0.102.072017/7/1915-1308主軸軟超速12.250.822017/7/1911-2111主軸超速模塊緊停11.885.432017/7/2011-2111高速軸轉速傳感器失效10.383.3502017/7/239-1104槳角編碼器偏差時間過長5.433.1502017/7/2444-2206安全鏈緊停5.432.900合計100.6044.622.21本月東汽平均故障處理響應時間為：2h。損失占發電〔％〕風機維護維保損失電量統計表損失占發電〔％〕日期風機編號原因停機總時長〔時〕損失電量kWh)2017/7/11-1111發電機找中3.200.002017/7/12-1110發電機找中2.200.002017/7/910-1105發電機找中1.980.002017/7/912-1106發電機找中1.820.002017/7/108-1108發電機找中2.330.002017/7/1011-1105發電機找中1.230.002017/7/114-1101衛生清掃5.580.002017/7/1213-1301發電機找中5.270.002017/7/129-1104發電機找中2.800.002017/7/1314-1302發電機找中2.150.002017/7/1321-1303發電機找中1.920.002017/7/1407-1304發電機找中4.900.00合計35.380.000風機巡視損失電量統計表日期風機編號原因停機總時長〔時〕損失電量kWh)2017/7/74-1101輪轂滲水原因檢查1.150.002017/7/75-1102輪轂滲水原因檢查1.230.002017/7/808-2108巡視1.830.002017/7/1920-1310巡視1.200.00損失占發電〔％〕2017/7/2001-1111消防檢查0.730.002017/7/2004-1101消防檢查0.770.002017/7/2204-1101月度巡視1.330.002017/7/2404-1101齒輪箱管接頭尺寸測量0.550.00合計8.800.000日期風機編號原因停機總時長〔時〕損失電量kWh)2017/7/1507-2107軸控柜溫度校準2.700.002017/7/1510-2110軸控柜溫度校準0.730.00損失占發電〔％〕2017/7/1611-2111軸控柜溫度校準0.950.002017/7/1612-2112軸控柜溫度校準0.780.00損失占發電〔％〕損失占發電〔％〕2017/7/1629-2306軸控柜溫度校準0.220.002017/7/1630-2307軸控柜溫度校準0.550.002017/7/1633-2310軸控柜溫度校準0.630.002017/7/1632-2309軸控柜溫度校準0.750.00合計7.320.000日期風機編號原因停機總時長〔時〕損失電量kWh)2017/7/64-1101軸3B編碼器更換1.532017/7/125-2105變槳驅動器拆除30.370.002017/7/1812-1106軸2充電器通訊故障2.000損失占發電〔％〕2017/7/1802-1110安全鏈復位繼電器二極管安裝0.1502017/7/1806-1103軸2充電器通訊故障1.5802017/7/1809-1104偏航安全鏈復位繼電器檢查0.500合計36.130.20日期風機編號原因停機總時長〔時〕損失電量kWh)2017/7/1403-2103主控程序升級0.130.002017/7/1404-2104主控程序升級0.130.002017/7/1408-2108主控程序升級2.680.002017/7/145-2105主控程序升級0.070.002017/7/1635-2312主控程序升級0.130.002017/7/1728-2305主控程序升級0.130.002017/7/1722-2409主控程序升級0.420.002017/7/1721-2408主控程序升級0.850.002017/7/1723-2410主控程序升級0.480.002017/7/1727-2304主控程序升級0.120.002017/7/1814-2401主控程序升級0.180.002017/7/1816-2403主控程序升級0.130.002017/7/1817-2404主控程序升級0.130.002017/7/1818-2405主控程序升級0.120.002017/7/1819-2406主控程序升級1.550.002017/7/1820-2407主控程序升級1.500.00合計8.760.000損失電量分析：風機故障損失電量%；0kWh0%；0kWh0%；0kWhkWh0.27%；3.7.60kWhkWh%。四、風機故障分析風機故障處理情況統計表日期日期風機編號原因故障處理情況更換備件2017/6/3020-13102檢查發現輪轂軸2BwordwordPAGEPAGE10/16消除檢查發現變槳驅動器3死機，復位2017/6/2925-2302變槳安全鏈斷開后風機恢復2017/7/1239-2201安全鏈緊停檢查發現變頻器安全鏈信號未上傳主控，緊固信號線后，風機恢復2017/7/1431-2308低速軸前軸承溫度高報警檢查發現風機低速軸PT100接線松動，緊固接線后，風機恢復2017/7/1408-2108變頻器故障檢查發現變頻器脫扣線圈卡澀，重裝脫扣線圈后風機恢復2017/7/1520-1310軸柜124V電源供電故障1400V啟后，風機恢復運行檢查發現變頻器直流母線欠壓，將2017/7/1511-1107變頻器故障機側模擬板與網測模擬板互換后觀察運行2017/7/1520-1310軸柜124V電源故障檢查發現軸柜124V電源模塊故24V電源模塊障，更換后風機恢復運行2017/7/1915-1308主軸軟超速升級主控程序后，故障消除2017/7/1911-2111主軸超速模塊緊停檢查發現風機低速接近開關損壞，2更換后風機恢復在19日故障處理過程中誤將發電2017/7/2011-2111高速軸轉速傳感器失效機與主軸超速信號接反，重新接線后故障消除檢查發現輪轂軸2編碼器B插頭進2017/7/239-1104槳角編碼器偏差時間過長水導致風機故障，清理插頭后故障消除2017/7/2444-2206安全鏈緊停檢查發現風機低速接近開關損壞，1更換后風機恢復2最大停機時長故障：#11-#2111五、風機遺留缺陷與處理建議故障停運風機：無。#11觀察中。六、本月完成工作風電場風機根底、箱變根底汛期巡查結果》；完成一期#43B完成一期風機塔筒內電纜保護絕緣皮統計；完成一期風機、箱變接地電阻測試報告編制；變根底汛期巡查結果》；6完成二期風機變槳軸控柜溫度校準；完成二期風機程序升級；完成一期、二期風機滅火器責任卡、標號制作；完成一期、二期組爬器操作提示卡、安全提示卡制作；完成風機安全警示牌統計；完成#47完成#8完成#810kV完成《#8QQ完成二期光伏集電線路跳閘故障排查；193、#4緣測試〔測試合格〕；完成二期光伏A30塔上AA絕緣支柱擊穿，現臨時更換為隔刀使用，待備件到貨后更換〕；完成東氣風機遺留缺陷統計并以函件發至東汽；七、需下月繼續完成的工作跟蹤風機塔筒電纜絕緣皮采購情況；6跟蹤二期風機主控?cái)?shù)據丟包處理后運行情況；跟蹤二期#5、#26“風機軸柜3超溫故障〞處理進度；跟蹤二期#8跟蹤一期風機找中進度；完成一期風機塔筒缺陷檢查統計；完成一期、二期風機滅火器責任卡、編號X完成一期、二期組爬器操作提示卡、安全提示卡X#8省調事宜；完成調試電腦程序安裝?！藏?fù)責人：黃忠〕20170726word附件-風機產能報表機位號發電量(kWh)發電小時數(h)平均風速(m/s)風機故障小時數〔h〕計劃停機小時數〔h〕非計劃停機小時數〔h〕利用小時數〔h〕可用小時數〔h〕備用小h〕1-1111108398219.462.720.003.930.0054.20720.00496.612-1110102483218.592.770.002.350.0051.24720.00499.063-110991697180.082.600.000.0045.85720.00539.794-1101101316181.622.6115.1810.9215.1850.66704.82512.285-1102104488199.202.712.831.232.8352.24717.17516.746-110374626179.872.470.000.000.0037.31720.00540.138-1108101193227.052.860.002.330.0050.60720.00490.629-110487377204.592.758.583.338.5843.69711.42503.5010-1105128962233.942.970.001.980.0064.48720.00484.0811-1107104467196.272.883.251.233.2552.23716.75519.2512-110697077224.682.830.003.820.0048.54720.00491.503111102084205.942.7429.8531.1229.8550.09717.29508.5011/16wordword7-130480236153.032.540.004.900.0040.12720.00562.0713-130182637169.872.640.005.270.0041.32720.00544.8614-130284426185.622.690.002.150.0042.21720.00532.2315-130856275141.622.3813.070.0013.0728.14706.93565.3116-130759752166.102.620.000.000.0029.88720.00553.9017-130949606123.102.180.000.000.0024.80720.00596.9018-130655306127.132.360.000.000.0027.65720.00592.8719-130558256134.712.390.000.000.0029.13720.00585.2920-131076666165.502.5613.732.2013.7338.33706.27538.5721-130387943172.632.580.001.920.0043.97720.00545.4522-131175535175.292.538.230.008.2337.77711.77536.4823-131263893153.332.400.000.000.0031.95720.00566.67313830531155.662.4935.0316.4435.0334.61717.08560.0503-210368761176.082.270.000.130.0034.38720.00543.7904-210467170181.012.290.001.580.0033.59720.00537.4112/16wordword05-210576876183.502.380.0031.430.0038.44720.00505.0706-210661278165.362.120.001.580.0030.64720.00553.0607-210779895186.992.280.002.700.0039.95720.00530.3108-2108107269220.962.595.124.525.1253.63714.88489.4009-2109118721243.782.750.000.000.0059.36720.00476.2210-2110115679249.082.790.000.730.0057.84720.00470.1911-211180225214.582.5531.050.9531.0540.11688.95473.4212-211293613247.572.760.000.780.0046.81720.00471.65321869487206.892.4836.1744.4036.1743.47716.38505.0539-220157192214.193.2115.980.0015.9828.60704.02489.8340-2202127285345.823.320.000.000.0063.64720.00374.1841-220363051260.752.850.000.000.0031.53720.00459.2542-2204105877293.693.240.000.000.0052.94720.00426.3143-220591549263.063.040.000.000.0045.77720.00456.9444-220683364272.862.858.330.008.3341.68711.67438.8113/16wordword45-2207131653318.013.480.000.000.0065.83720.00401.9946-220878046248.433.360.000.000.0039.02720.00471.5747-2209116387264.463.850.000.000.0058.19720.00455.5448-221076442294.212.890.000.000.0038.22720.00425.7949-221179975306.303.100.000.000.0039.99720.00413.7050-221274275287.273.000.000.000.0037.14720.00432.733221085096280.753.1824.320.0024.3245.21717.97437.2224-2301231301396.503.720.000.000.00115.65720.00323.5025-2302204597362.063.5710.850.0010.85102.30709.15347.0926-2303208069356.993.520.000.000.00104.03720.00363.0127-2304154486310.243.030.000.120.0077.24720.00409.6428-2305175539315.663.230.000.130.0087.77720.00404.2129-2302107045236.502.580.000.220.0053.52720.00483.2830-230384269228.742.490.000.550.0042.13720.00490.7131-230492038229.852.573.820.003.8246.02716.18486.3314/16wordword32-230597197249.702.6010.050.7510.0548.60709.95459.5033-230687122228.562.430.000.630.0043.56720.00490.8134-230394887245.062.570.000.000.0047.44720.00474.9435-230492193250.132.600.000.130.0046.10720.00469.74323162874