YC橡套電纜技術參數

1、YC橡套電纜技術參數型號芯數X平方mmkg/kmA規格電纜外徑理論重量載流量YC2X 12 X 1.52 X 2.511.12165.84202X 412.82227.29262X 614.40293.87332 X 1019.52575.35472 X 1623.00768.09622 X 2527.801110.39842 X 3532.181488.801002 X 5037.281997.121252 X 7042.242621.531602 X 9546.703328.672002 X 120230YC3X 13 X 1.53 X 2.511.91216.21163X 413.733

2、00.17213X 615.40397.17283 X 1020.95763.38393 X 1624.001023.08533 X 2529.791490.06733 X 3534.461974.22913 X 5030.872702.181103 X 7045.183570.461403 X 9550.134580.421803 X 12054.505603.61210YC3X 1.5+1 X 13 X 2.5+1 X 1.512.92261.53163X 4+1 X 2.514.68355.07313 X 6+1 X 416.6476.63383 X 10+1 X 621.2797.18

3、393 X 16+1 X 624.961110.26533X 25+1 X 1030.671628.45733X 35+1 X 1034.092090.33913X 50+1 X 1640.893018.411103X 70+1 X 2546.133864.721403X 95+1 X 3550.584957.481803X 120+1 X 3553.755869.51310用途：本產品用于交流額定電壓Uo/U 450/750V及以下動力,家用電器及各種移動或電氣設備和工具用。二、性能：（一）通用橡套軟電纜：1、產品依據 GB5023-1997 及 JB8735-1998 標準。2、 電纜長期

4、允許工作溫度應不超過65C;3、W型派生電纜具有耐氣候和一定的耐油性能，適宜 于在戶外或接觸油污的場合使用；4、成品電纜應經受下表規定的電壓實驗。實驗條件單位額定電壓V300/300 300/500450/750試樣長度m整卷整卷溫度C室溫室溫實驗電壓v20002500電壓施加時間min55（二）電焊機電纜:1、產品依據GB5023-1997標準;2、電纜的長期允許工作溫度應不超過65 C;3、成品電纜應經受表A規定的交流50Hz浸水電壓實驗;4、成品電纜應經受表B規定的交流50Hz浸水電壓實驗;5、成品電纜應經受表C規定的靜態曲線實驗。表A護套厚度 S mm試驗電壓 V2.060002.0V

5、3.070002.5V3.080003.0V3.510000實驗條件單位性能要求試樣長度最小m10浸水時間最小h1水溫C20試驗電壓值v2000施加電壓時間最小min5標稱截面mm2最大距離Lem標稱截面mm2最大距離Lem1045705516459560254512065355015070505018575（三）橡套電纜的型號名稱型號名稱用途YQ ,YQW輕型橡套軟電纜用于各種移動電器設備及工具YZ , YZW中型橡套軟電纜YC,YCW重型橡套軟電纜YH天然膠護套電焊機電纜用于連接電焊機及焊鉗電纜YHF氯丁膠或其他相當?shù)暮铣赡z彈性護套電焊機電纜橡套電纜的生產范圍:型號額定電壓芯數標稱截面mm

6、2YQ YQW300/5002、30.3-0.5YZ YZW450/7502、3、4、50.75-6YC YCW450/75011.5-40021.5-953、41.5-10551.5-25YH YHW200110-120注：根據用戶需要，還可生產以上規格外的產品（四）通用橡套軟電纜長期允許載流量導線工作溫度：65 C環境溫度：25 C導線截面mm2空氣敷設長期允許載流量 AYQ、YQWYZ、YZWYC、YCW、-H-芯三芯心三心四芯一芯心三心四芯0.3760.5119121090.75141214121111714131.521181822622222.5302525373026274413

7、5364739343465345455251434410757463631611298848425148135115116351831671421435022620817617770289259224224953533182732731204153713163160.6/126/35kV 塑料絕緣高阻燃（隔氧層）電力電纜Plastic In sulated High Performa nee Flame-retarda nt Power Cable產品標準Standard本產品按GB12706-91額定電壓35KV及以下銅芯、鋁芯塑料絕緣電力電纜、GB12666.5-90電線電纜成束燃燒試驗、

8、GB/T17650-1998取自電纜或光纜的材料燃燒時釋岀氣體的試驗方法和GB/T17651-1998電纜或光纜在特定條件下燃燒的煙密度測定標準生產0.6/1kv26/35kv塑料絕緣電力電纜，同時還可根據用戶需要按國際電工委員會推薦標準IEC、英國標準、德國標準及美國標準生產。The product is manufaetured aeeording to the standard of GB12706-91、GB12666.5-90、GB/T17650-1998 and GB/T17651-1998 or IEC and DIN and ICEA.適用范圍Applieations本產品適用

9、于工頻額定電壓0.6/1kv26/35KV輸配電線路作配送電能之用。The produet is suitable for power transmission and distribution lines with rated voltage0.6/1kv26/35kv.使用特性 Operating eharaeteristies .工頻額定電壓 Uq/U為0.6/1kv26/35kv.Rated power freque ncy voltage Uo/U:O.6/1KV26/35KV.PVC絕緣電纜導體的長期最高工作溫度為70C。XLPE絕緣電纜導體的長期允許最高工作溫度為90CPVC i

10、nsulated power eable Max . permissible continuous operating temperature ofthe eonduetorshould not exceed 70C ,XPLE permissible eontinuous operating temperatureof the eonduetorshould not exceed 90 C.短路時(最長持續時間不超過5s)電纜導體的最高溫度不超過250Max Short eireurrt temperature of eon duetor shall not exceed 25O.(5s m

11、aximum durati on)電纜敷設時環境溫度不低于0CThe in stallati on temperature should n ot below 0C電纜阻燃性能滿足GB12666.5-90標準A類相應指標要求。The flame-ratardant properties of eable comply with the requirements specified in A kind ofGB12666.5-90低鹵電纜除應滿足GB12666.5-90標準中A類相應指標要求外，還應滿足GB/T17650.1-1998標準規 定的相應指標。The flame-retardant

12、properties of lower halogen cable comply with requirements specified inA kind of GB12666.5-90 except compluing with requirements specified in GB/T17650.2-1998 .無鹵電纜除應滿足 GB12666.5-90 標準中 A 類相應指標要求外，還應滿足GB/T17650.2-1998 和GB/T17651-1998 標準規定的相應指標。The flame-retardant properties of no halogen cable compl

13、y with requirements specified in A kind of GB12666.5-90 except compluing with requirements specified in GB/T17650.2-1998 .andGB/T17651-1998.電纜彎曲半徑：三芯電纜不小于電纜外徑 15 倍；單芯電纜不小于電纜外徑 20 倍。Three bending radius of a single core should not less than 20 times of the cable diameterTwo bending radius of a three-

14、core cable should not less than 15 times of the cable diameter.電纜額定電壓的選擇 Voltage designation電纜額定電壓應適合于電纜的系統的運行狀況，用Uo/U ( Un)表示，均為有效值，單位為kvU0- 電纜設計用導體與屏蔽或金屬套之間的額定工作電壓；U電纜設計用導體之間的額定工頻電壓；Un -設備可承受的“最高系統”電壓的最大值。The rated voltage of the cable for a given application shall be suitable for the operatingcon

15、dition in the systen in which the cable is used , and is expressed in the forn of U0/U ( Un)are applied to the systen voltages and running state , and expressed in the forn U0/Ukv.U0-The rated power-frequency voltage between conductor and earth or netallic screen ,for which the cable designed .U-The

16、 rated power freque ncy voltage betwee n con ductors for which the cable desig ned.Ut- - The maximum value of “the highest system voltage ” for which the equipment may be used.三相系統用電纜的 Uo值推薦如下表：The values U 0 recommended for cables to be used in three-phase systems are listed below:第一類一一用于單相接地故障時間每一

17、次一般不大于1min，亦可用于最長不超過8小時，每年累計不超過 125 小時的系統。第二類用于接地故障時間更長的系統及對電纜絕緣性能要求較高的場合。The first class cable suitable for one single phase earthing block time does not exceedone minute each time. Max. time not exceed 8 hours ,and not exceed 125 hours in all in one year. The second class cable suitable for more t

18、he earthing block time and more better insulatedperforma.電纜的型號 Type of cable 0.6/1kv高阻燃（隔氧層）電纜的生產范圍retarda nt cableProducti on Range of high performa nee flame1.8/326/35kv高阻燃(隔氧層)電纜的生產范圍Producti on Range of high performa nee flame- retarda nt cable型號Type芯數cores電壓 Rated voltage kv銅芯 Copper conductor鋁

19、芯 Aluminum conductor1.8/33.6/66/66/108.7/108.7/1512/2018/3026/35標稱截面 Nominal Cross-section Mm 2GZR-YJV GZR-DL(WL)-YJVGZR-YJLV GZR-DL(WL)-YJLVGZR-YJV22GZR-YJLV221063025630256303563035630GZR-DL(WL)-YJV22GZR-DL(WL)-YJLV2211063025630256303563035630GZR-YJV32GZR-YJLV321063025630256303563035630GZR-DL(WL)-Y

20、JV32GZR-DL(WL)-YJLV32GZR-YJV GZR-DL(WL)-YJVGZR-YJLV GZR-DL(WL)-YJLVGZR-YJV 22GZR-YJLV 221050025500255003550035500GZR-DL(WL)-YJV22GZR-DL(WL)-YJLV2231050025500255003550035500GZR-YJV 32GZR-YJLV 321050025500255003550035500GZR-DL(WL)-YJV32GZR-DL(WL)-YJLV32注：單芯鎧裝型高阻燃(隔氧層)電纜僅用于直流系統，應采用非磁性材料的鎧裝層或采用隔磁措施。Note

21、: The single-core armoured high performanee flame-retardantcables are used for d.c systemonly, as for a . c. system non-magnetic aromour materials should be or magnetic isolation should be applied.電纜結構圖 0, 6/ lli 韭鎧激型電纜I n fi nnn 11 n(I iblr411JhruhK ior迪泡 LisiilatiohIi7i Sffjarat - oxygen h|包舉T珂粹外護

22、資0w sheath電纜主要技術參數Main tech nical data of cable20C時導體最大直流電阻Max.D.C resista nee of con ductor at 20C電壓試驗、局部放電試驗 Voltage test and partial discharge導體短路電流 Short - circuit current電容、電感(參考值)Capacita nee and in ducta nee of cable (refere nee value)電容 Capacita nee單芯電纜電感 In ducta nee of sin gle core cable三芯電纜電感 In ducta nee of three cores cable電流載流量 The current carrying capacity0.6/1kv 聚氯乙烯絕緣電力電纜0.6/1kv PVC in sulated power cable (A)在土壤中的敷設 Buried (A)0.6/1KV 交聯聚氯乙烯絕緣非鎧裝型電力電纜0.6/1kv XPLE insulated unarmoured power cable (A)0.6/1KV 交聯聚乙烯絕緣鎧裝型電力電纜0.6/1kv XLPE insulated armoured power ca