GB 26722-2024索道用鋼絲繩

ICS77.140.65

CCSH49

中華人民共和國國家標準

GB26722—2024

代替GB/T26722—2022

索道用鋼絲繩

Steelwireropesforropeway

2024?06?25發布2024?09?25實施

國家市場監督管理總局

國家標準化管理委員會發布

GB26722—2024

目次

前言··························································································································Ⅲ

1范圍·······················································································································1

2規范性引用文件········································································································1

3術語和定義··············································································································1

4分類·······················································································································1

5訂貨內容·················································································································3

6鋼絲繩材料··············································································································4

7技術要求·················································································································5

8檢查與試驗方法······································································································16

9驗收·····················································································································19

10包裝、標志及質量證明·····························································································19

附錄A（規范性）鋼絲繩力學性能表················································································20

附錄B（資料性）鋼絲繩選用和貯存················································································37

附錄C（資料性）鋼絲繩公稱金屬橫截面積和外層鋼絲近似直徑計算······································38

附錄D（規范性）鋼絲繩參考重量和最小破斷拉力計算、密封鋼絲繩鋼絲破斷拉力總和計算·········40

參考文獻····················································································································42

Ⅰ

GB26722—2024

前言

本文件按照GB/T1.1—2020《標準化工作導則第1部分：標準化文件的結構和起草規則》的規

定起草。

本文件代替GB/T26722—2022《索道用鋼絲繩》，與GB/T26722—2022相比，除結構調整和編輯

性改動外，主要技術變化如下：

——增加了6×49SWS、6×55SWS、6×K49SWS和6×K55SWS等4個鋼絲繩典型結構（見表1）；

——更改了6×36WS、6×K36WS等2個結構鋼絲繩的直徑范圍（見表1，2022年版的表1）；

——?jiǎng)h除了彈性模量相關要求（見2022年版的7.7和8.1.5）；

——更改了鋼絲繩直徑測量方法（見8.1.1.3，2022年版的8.1.1.3）；

——?jiǎng)h除了鋼絲繩伸長率和彈性模量試驗方法（見2022年版的附錄D）。

請注意本文件的某些內容可能涉及專利。本文件的發布機構不承擔識別專利的責任。

本文件由中華人民共和國工業和信息化部提出并歸口。

本文件及其所代替文件的歷次版本發布情況為：

——2011年首次發布為GB26722—2011；

——2022年第一次修訂為GB/T26722—2022；

——本次為第二次修訂。

Ⅲ

GB26722—2024

索道用鋼絲繩

1范圍

本文件規定了索道用鋼絲繩的分類、訂貨內容、鋼絲繩材料、技術要求、檢查與試驗方法、驗收、包

裝、標志及質量證明。

本文件適用于拖牽索道、地面纜車、客運及貨運架空索道等用途的圓股鋼絲繩、壓實股鋼絲繩、異

形股鋼絲繩及密封鋼絲繩。

2規范性引用文件

下列文件中的內容通過文中的規范性引用而構成本文件必不可少的條款。其中，注日期的引用文

件，僅該日期對應的版本適用于本文件；不注日期的引用文件，其最新版本（包括所有的修改單）適用于

本文件。

GB/T228.1金屬材料拉伸試驗第1部分：室溫試驗方法

GB/T238金屬材料線材反復彎曲試驗方法

GB/T239.1金屬材料線材第1部分：?jiǎn)蜗蚺まD(zhuǎn)試驗方法

GB/T1839鋼產品鍍鋅層質量試驗方法

GB/T2104鋼絲繩包裝、標志及質量證明書的一般規定

GB/T8358鋼絲繩破斷拉力測定方法

GB/T8706鋼絲繩術語、標記和分類

GB/T15030劍麻鋼絲繩芯

GB/T21965鋼絲繩驗收及缺陷術語

GB/T43357鋼絲繩一般性能試驗方法

NB/SH/T0387—2023鋼絲繩用潤滑劑

YB/T081冶金技術標準的數值修約與檢測數值的判定

YB/T4452鋼絲繩纖維芯

YB/T4643制繩用異形鋼絲

YB/T5343—2015制繩用圓鋼絲

3術語和定義

GB/T8706界定的以及下列術語和定義適用于本文件。

3.1

復合鋼芯c