DBJ∕T 13-176-2013 鋁合金電纜工程設計、施工及驗收規程

工程建設地方標準編號：DBJ/住房和城鄉建設部備案號：J124鋁合金電纜工程設計、施工及驗收規程CodeforDesign,InstallofAluminumAlloyCableengineering2013－08－09發布2013－10－01實施鋁合金電纜工程設計、施工及驗收規程CodeforDesign,InstallofAluminumAlloyCableengineering工程建設地方標準編號：DBJ/住房和城鄉建設部備案號：J124由福建省建筑設計研究院主編的《鋁合金電纜工程設計、施工及驗收規《關于報送福建省工程建設地方標準<鋁合金電纜工程設計、施工及驗收規“中華人民共和國工程建設地方標準”備案，其備案號：該三項標準的備案公告，將刊登在近期出版的《工程建設標準化》刊物（閩建科【2012】23號）的要求，規程編制組經廣泛調查研究，結合我省當前實際情況，總結近年來的實踐經驗，參考有關國家現行相本規程由福建省住房和城鄉建設廳負責管理，或建議反饋給福建省住房和城鄉建設廳建筑節能本規程參編單位：福建省工程建設科學技術標美國通用電纜（中國加鋁（天津）鋁合金產品有限公司） 3 3 4 64.2運輸與保管 7 8 2 3 6 1.0.1為適應工程建設的需要，規范鋁合金電纜工程在設計、施工及驗收各環節的應用，1.0.3本規程不適用于制造、貯存、使用火藥、炸藥等爆炸物質的場所。嚴重腐蝕性環境1.0.4鋁合金電纜工程的設計、施工及驗收除應符合本規程外，尚應符合國家現行有關標2安裝在電纜末端，以保證與該系統其他部分的電氣連接并保持絕緣至連接點33.1.2鋁合金電力電纜及附件的性能應符合國家標準及相關3.1.3一類高層建筑以及重要的公共場所等防火要求高的建筑物，應采用阻燃低3.2.2按載流量選擇電纜時，應根據不同環境溫度、成束敷設數量、槽盒層數、IZ=I×K1×K2×K3×K4（3.2.2）I——單根電纜在特定條件下敷設基準載流量值（A43.2.3按照電壓損失校驗截面時，各種用電設備端電壓應符合電壓偏不超過5s時短路溫度應不大于250℃。IS≥t（3.2.5Ik3.2.6電纜成束敷設時，應采用阻燃型電線電纜電纜通道內所有電纜的非金屬材料體積總量，按《阻燃和耐火電線電纜通則》3.2.7鋁合金電纜的中性線、PE線截面選擇應滿足《低壓配電設計規范》GB53.3.4交流系統用單芯電力電纜的相序配置及其相間距離，應同時滿截面的20％；在托盤和梯架內敷設，不應大于其橫斷面的40％。4電纜總截面（包括外護層）不應大于保護管內徑面積的40%；62電纜溝或電纜隧道的深度、寬度，電纜托盤、梯架、槽盒或電纜導管的型3按施工圖紙和實際敷設路徑對電纜敷設長度進行測量并分別編號，合理安20℃導體最大直流電阻(Ω/km)25355070952403004005007電纜的壓接工具、壓接工序及附件應符合相關標準要求，并應確保電纜終74.1.2施工現場應準備電纜牽引、導向、支撐、端接及其4.1.4電纜敷設的安全技術措施，應符合本4.2.1電纜及附件的運輸與保管，應符合產4.2.3運輸或滾動電纜盤前，必須保證電纜盤牢固，電纜繞緊。滾動時必須順著1電纜應集中分類存放，并應標明型號、電壓、規格、長度有通道；地基應堅實，當受條件限制時，盤下2電纜附件的防潮包裝應密封良好，并應根據材料性能和保管要求貯存和保4電纜在保管期間，電纜盤及包裝應完好，標志應齊全，封端應嚴密。當有84.3.1電纜宜避開可能受到機械外力損傷、4.3.2并聯使用的電力電纜，其長度、型4.3.4單芯電纜的排列應符合設計要求；三相或單相的交流單芯電纜不得單獨穿4.3.5建筑物內部敷設電纜，宜采用從上往下的方向敷設。水平敷設電纜應將電電纜引入分支箱或終端箱時，電纜距箱體300mm之內應設固定點。4.3.8低溫下電纜敷設時，敷設前應將電纜儲存在溫度為室溫（或更高）的環境4.3.9電纜沿槽盒、托盤或梯架敷設，排列應整9建筑物，穿越街道或公路時均應穿保護管保其他硬質雜物，并加蓋保護板，其覆蓋寬度應超過電纜兩側各50mm，保護板可3根據線芯連接金具套接長度剝除線芯絕緣，剝4鎧裝電纜的中間接頭處應保證兩根電纜鎧裝之間的電氣和機械性能的恢5最外側熱縮管的兩端應采用防水帶覆蓋，并用PVC絕緣膠帶包覆。4.4.3電纜附件應具有匹配檢測報告。端子123456784.4.4鋁合金電纜與微型斷路器的連接，宜采用針4.4.5鋁合金電纜的分支宜通過銅排轉接、絕緣穿刺線夾或分支連接器在分支接5.1.1隱蔽工程應在施工過程中進5.1.2在驗收時，施工單位應提交5.3.1電纜及附件的型號、規格應符合設計要求，進場檢驗應符合本規程第4.15.3.3電纜終端、電纜接頭應固定牢靠5.3.4電纜線路所有應接地的接點應與5.3.7直埋電纜路徑標志，應與實際路徑相符；路環境溫度(℃)202530354045505560校正系數空氣0.960.910.870.820.760.71土壤0.960.930.890.850.800.760.710.652.002.503.00校正系數電纜穿管埋地0.96電纜直接埋地0.93導體截面(mm2)2535507095240300400500短路時間0.01s23.532.947.065.889.3112.8141.0173.9225.6282.0376.0470.00.05s6.721.029.439.950.563.177.8100.9126.1168.2210.20.1s4.87.420.828.235.744.655.071.389.2118.9148.60.5s2.13.34.76.79.324.631.939.953.266.52.43.34.76.68.922.628.237.647.05s0.72.12.94.05.06.37.821.0電纜根數電纜根數23456電纜根數23456回路數觸）23456123469112131111-21-31-112111-21-112131111111-21-31-2、所給值用于兩個托盤間垂直距離為300mm而托盤與墻之間間距不少于20mm的情況，小于這一距離時12345678911多于9個回路或9根多芯11注：1、本表格中的系數適用于尺寸和負荷2、相鄰電纜水平間距超過了2倍電纜外徑時，則不需要降低。導體截面(mm2)35507095240≤1kV0.990.990.990.990.980.970.960.94注：運用本表系數時，先按室外無遮陽環境溫度確定載流量，再乘以注：1、當電纜垂直敷設且通風受限制時，應注意垂直部分頂部的環境溫度升高非在使用機械敷設大截面電纜時，應在施工措施中確定敷設方法、線盤架設位置、電纜牽引方向，并校核牽引力。電纜敷設時的實際牽引力應小于電纜的容許拉力。聯鎖鎧裝層上能承受的最Tm=S×σ式中：Tm——電纜容許牽引拉力（N（C.0.2）Hm——滑輪軸心至托架的高度（m電纜安裝時可采用滑輪組完成轉彎，滑輪組的安裝應保證電纜彎曲順暢，并應檢查滑輪槽的電纜經過導輪轉彎敷設時，應避免轉彎處的側壓力過大而使電纜損傷。轉彎處的容許拉力應P——容許側壓強度（N/m）,合金鎧裝電纜取4380；2《額定電壓35kV(Um=40.5kV)及以下電力電試驗方法和要求》6《阻燃和耐火電線電纜通則》7《低壓配電設計規范》8《電氣裝置安裝工程：電纜線路施工及驗收規范》9《電力工程電纜設計規范》鋁合金電纜工程設計、施工及驗收規程CodeforDesign,InstallofAluminumAlloyCableengineering工程建設地方標準編號：DBJ/T13-176-2013住房和城鄉建設部備案號：J-2013本規程是為適應工程建設的需要，規范鋁合金電纜工程在設計、施工及驗收各環達到節約銅資源，提高工程質量，推廣鋁合金電纜的應用，在省住房和城鄉建設廳指導下，本規程經廣泛深入的調查研究，參考全國不同地區鋁合金電纜應用的實踐經驗，結合《鋁合金電纜工程設計、施工及驗收規程》編制組按章、節、條順序編制了本規程條文說明，對條文規定的目的、依據、以及執行中需注意的有關事項進行了說明。但是，本條文說明不具備與規范正文同等的法律效力，僅供使用者作為理解和把握標準規 1.0.1鋁合金電纜在工程應用中的設計、安裝結構型式新穎，為確保工程質量，在使用和安裝上需要3.1.1電纜的設計選用與建筑物的環境特征、使用要求、敷設條件及電纜的性能特點等因素密切相關。加鋁（天津）鋁合金產品有限公司的STABILOY-AC90AA8030鋁合金導體交聯聚乙烯絕緣鋁合金聯鎖鎧裝電力電纜，低煙無鹵阻燃A類，導體最高運行溫度90℃,電纜最低運行溫度-40℃。乙烯護套電力電纜，阻燃B類，導體最高運行溫度90℃,電纜最低運行溫度-40℃。STABILOY-TC90AA8030鋁合金導體交聯纜，阻燃C類，導體最高運行溫度90℃,電纜最低運行溫度-40℃。表1鋁合金電纜的型號及適用范圍3~53~5隧道、室外/室內臨時電敷設、潮濕及腐蝕環境3.2.1本條提出了按照截面積選擇電纜時的一些依據電纜類型、敷設方式、環境溫度、并列電纜根數等實際情況，表2～表9列出了加鋁（天津）鋁合金產品有限公司的世德合金電纜載流量數據。所列載流量數據進行了重新編排和計算。根據福建省地區環境條件，對空氣中敷設的電纜給出線電纜載流量修正系數詳見GB/T16895.15-2002。合金電纜的載流量依據JB/T高。部分型號電纜經過國家電線電纜質量監督檢驗中心的載流量試驗，檢測結果與表2STABILOY-AC90鋁合金電纜在空氣中明敷的載流量環境溫度30℃35℃40℃根數導體導體三芯帶負荷鋁合金導體電纜載流量(A)E（敷設在梯架、托架或金屬網格式橋架上、吊裝在懸索上、敷設在在空氣中）截面(mm2)766662616160605959736360585858585757706157565655555555258984828281818080988580787877777676948277757574747373359999989898969695959494949292919190905070952392082292002202802442302242242212212182182692342202152152122122102102582252122062062042042012013242822662592592562562532533112712552492492462462432432992602452392392362362332333723243052982982942942902903573112932862862822822792793432982812742742712712672672404393823603513513473473423424213673463373373333333293294053523323243243203203163163005084424174064064014013963964884244003903903853853803804684073843753753703703653654006095304994874874814814754755855094794684684624624564565614884604494494434434384382、相鄰電纜水平間距超過了2倍電纜外徑時，則不需要降低載流量。表3STABILOY-AC90鋁合金電纜沿墻敷設的載流量環境溫度30℃35℃40℃根數三芯帶負荷鋁合金導體電纜載流量(A)導體截面(mm2)C（電纜敷設在水平或垂直的無孔托盤內、敷設在木質墻上、直接埋設在磚石墻內（墻的熱阻系數不大于2(K·m)/W））71606053525151505068585851504949484865565649484747464625948080716968686766907777686665656463877474656362626261359999878584848281959584818080797891918078777776755098989797969470952212122042592202202492112112392032032992542542242182152152122092872442442152102072072042012762342342072013422912912572502462462432393282792792462402362362332303152682682362302272272242212404043433433032952912912872833883303302912832792792752713723163162792722682682642613004663963963503403363363313264473803803363273223223183134293653653223143093093053014005584744744194074024023963915364554554023913863863803755144374373863753703703653602、相鄰電纜水平間距超過了2倍電纜外徑時，則不需要降低載流量。環境溫度25℃土壤熱阻系數電纜根數三芯帶負荷鋁合金導體載流量(A)導體截面(mm2)D2（直接敷設在土壤中）6348413835327959514743399168595550462581605248444075656055508775706458359773635853489078726660918477705088767064599487807393847092857871968720395938521124595236274205215267200310232201241299224347260226208240277208344258224206400300260240220200300313235203388291252233213451338293270248225400365274237219201452339294271249226525394341315289263環境溫度30℃35℃40℃電纜根數三芯帶負荷鋁合金導體載流量(A)導體截面(mm2)E（敷設在梯架、托架或金屬網格式橋架上、吊裝在懸索上、敷設在在空氣中）786864626262626161756561606059595858726359585857575656259085838382828181878280807979787896837977777676757535989897979696979494939392925070952402092302002212802442302242242212212182182692342202152152122122102102582252122062062042042012013232812652582582552552522523102702542482482452452422422982592442382382352352322323693213032952952922922882883543082902832832802802762763402962792722722692692652652404333773553463463423423383384163623413333333283283243243993473273193193153153113113004994344093993993943943893894794173933833833783783743744604003773683683633633593594005935164864744744684684634635694954674554554504504444445474754484374374324324264262、相鄰電纜水平間距超過了2倍電纜外徑時，則不需要降低載流量。環境溫度30℃35℃40℃根數三芯帶負荷鋁合金導體載流量(A)導體截面(mm2)C（電纜敷設在水平或垂直的無孔托盤內、敷設在木質墻上、直接埋設在磚石墻內（墻的熱阻系數不大于2(K·m)/W））73625855535353525170605553515050504967575350494848484725978277737170706968937974706867676665897671676564646363359489878686848397908683828281809387828079797877509999979670952242152062632242082522152422063032582392272212182182152122912472302182122092092072042792372212092042012013462942732602532492492462423322822622492422392392362333192712522392332302302262232404073463223052972932932892853913323092932852812812772743753192962812742702702662633004693993713523423383383333284503833563383293243243203154323673413243163113113073034005584744414194074024023963915364554234023913863863803755144374063863753703703653605006385425044794664594594534476125214844594474414414354295885004654414294234234174122、相鄰電纜水平間距超過了2倍電纜外徑時，則不需要降低載流量。環境溫度30℃35℃40℃根數三芯帶負荷鋁合金導體載流量(A)導體截面(mm2)B2（敷設在木質或磚石墻上的導管中、敷設在懸吊的電纜槽盒內、敷設在磚石墻隔熱墻內的鋼管中）625043403735333231604842393634323130574640373433313029258266575349474443417963555147454341397660534945434139383580706560575452509677676258555250489274656055535048465089837672696664988579736966636194827670676361597096918683809288838077968884807774959696929692882292202112612092512002413052442142932342052812252403552842492312132023412732392222043272622292133004053242842632432312192112033893112722532332222102023732992612432242132024004773823343102862722582482394583663212982752612472382294403523082862642512372292205005704563993713423253082962855474383833563283122952852745254203683413152992842732632、相鄰電纜水平間距超過了2倍電纜外徑時，則不需要降低載流量。環境溫度30℃35℃40℃根數三芯帶負荷鋁合金導體載流量(A)導體截面(mm2)E（敷設在有孔托盤上（托盤面積大于等于底面積的30%））7869646059575756567566615856555554547263595554525252522591847977757574749987817674727271719584787371696968683598959393919194918989888896908885858484507095240211230203221281247230216211205205202202270237221208202259228212324285266249243237237233233311274255240233227227224224299263245230224218218215215371326304286278271271267267356313292274267260260256256342301280263256250250246246240437385358336328319319315315420369344323315306306302302403354330310302294294290290300504444413388378368368363363484426397373363353353348348464409381358348339339334334400601529493463451439439433433577508473444433421421415415554487454426415404404399399500687605563529515502502495495660580541508495481481475475633557519488475462462456456注：1、本表根據適用于敷設在空氣中的32、相鄰電纜水平間距超過了2倍電纜外徑時，載流量校正系數會高一些，需環境溫度25℃土壤熱阻系數電纜根數三芯帶負荷鋁合金導體載流量(A)導體截面(mm2)D1（穿管敷設在土壤中）53454037343261524643393666565046434025675750474440776658545046847163595550358472635955519783736863589079746963508777726762898377719690837770958982769587959597902082262042342542162332682282012922482192042402692282023092632322162013362862522352182023003092632322162013553022672492312133863282902702512324003593052692512332154133513102892682484493813373142922695004123503092882682474744033553323082845154383863603353093.2.3加鋁（天津）鋁合金產品有限公司的世德合金電纜線路的電壓損失值可按表的“多芯電纜三相380V系統電壓降”和“單芯電纜三相380V系統電壓降”。表10多芯電纜三相380V系統電壓降導體截面直流交流功率因數(mm2)(Ω/km)(Ω/km)(Ω/km)(Ω/km)0.50.60.70.80.850.91.7762.2052.2760.0800.5340.6320.7300.8260.8740.9201.005251.1361.4111.4570.0810.3530.4150.4770.5370.5660.5950.643350.8121.0081.0410.0780.2610.3040.3470.3890.4090.4290.460500.5680.7060.7290.0750.1900.2200.2500.2780.2910.3040.322700.4060.5040.5200.0740.1440.1650.1850.2040.2130.2220.230950.2990.3720.3840.0720.1130.1280.1420.1550.1620.1670.1700.2370.2940.3040.0710.0950.1070.1170.1270.1310.1350.1350.1890.2360.2430.0710.0820.0910.0990.1060.1090.1110.1080.1540.1910.1970.0720.0720.0790.0850.0900.0920.0930.0882400.1180.1480.1520.0710.0620.0670.0710.0740.0750.0750.0683000.0950.1180.1220.0700.0550.0580.0610.0630.0630.0630.0554000.0710.0890.0920.0700.0480.0510.0520.0530.0520.0520.0425000.0570.0720.0740.0690.0450.0460.0470.0460.0460.0450.034注：環境溫度為30℃,電纜運行溫度為80℃。表11單芯電纜三相380V系統電壓降導體截面外徑導體外徑三角形排列電壓損失(%/(km·A))緊靠排列電壓損失(%/(km·A))有間距排列電壓損失(%/(km·A))(mm2)(mm)(mm)0.70.80.90.70.80.90.70.80.99.44.700.7300.8260.9201.0050.7340.8300.9231.0050.7630.8540.9411.005255.860.4770.5370.5950.6430.4810.5410.5980.6430.5100.5640.6150.643356.950.3470.3890.4290.4600.3520.3930.4320.4600.3800.4170.4490.460508.240.2500.2780.3040.3220.2540.2820.3070.3220.2830.3060.3250.322709.720.1850.2040.2220.2300.1900.2080.2250.2300.2180.2320.2420.2309511.350.1420.155 0.167 0.1700.1470.1590.170 0.170 0.1750.1830.1870.17012.800.1170.1270.1350.1350.1220.1310.1380.1350.1500.1550.1550.13520.414.400.0990.1060.1110.1080.1030.1100.1140.1080.1320.1340.1310.10822.415.950.0850.0900.0930.0880.0890.0940.0960.0880.1180.1180.1130.08824025.018.230.0710.0740.0750.0680.0750.0780.0780.0680.1040.1020.0960.06830027.720.510.0610.0630.0630.0550.0660.0670.0660.0550.0940.0910.0840.05540031.523.660.0520.0530.0520.0420.0570.0570.0540.0420.0850.0800.0720.04250035.226.460.0470.0460.0450.0340.0510.0500.0480.0340.0800.0740.0650.034表12成束阻燃性能要求/（L/m）71）試樣上炭化的長度不應超過距噴嘴底2）停止供火后試樣上的有焰燃燒時間不表13鋁合金電纜的非金屬含量表導體截面鋁合金電力電纜非金屬含量(L/m)STABILOY-AC90STABILOY-ACWU90STABILOY-TC90(mm2)3+1芯4芯4+1芯3+1芯4芯4+1芯3+1芯4芯4+1芯0.0260.0380.0040.0490.0580.0910.1100.1260.1340.1540.1120.1210.1210.1350.132250.0460.0670.0800.0880.1010.1520.1870.2100.2260.2500.1930.2210.1980.2400.227350.0540.0780.0990.1030.1240.1790.2150.2490.2610.3020.2430.2470.2640.2710.304500.0700.1020.1230.1350.1560.2200.2650.2980.3230.3630.3060.3120.3050.3540.354700.0870.1270.1510.1680.1920.2650.3220.3650.4020.4610.3720.4020.3940.4390.424950.1010.1480.1800.1950.2270.3140.3980.4540.4950.5540.4580.4760.4580.5310.5330.1230.1810.2210.2390.2790.3810.4680.5370.5830.655-0.5870.5680.6710.6270.1600.2360.2750.3110.3510.4580.5690.6340.7080.795-0.7260.6630.8190.7420.1980.2920.3390.3870.4340.5540.6870.7660.8570.948-0.9070.8191.0180.9302400.2390.3530.4110.4680.5260.6580.8170.9111.0281.126-1.0901.0281.2501.1433000.2840.4190.4940.5550.6310.7700.9671.0961.2141.360-1.3041.2381.4921.3944000.3580.5300.6240.7030.7970.9681.2071.3451.5201.666-1.6421.5011.8401.7315000.4300.6380.0730.8470.9551.1281.4141.5761.7871.959-1.9671.8002.2292.060注：非金屬含量用于確定所需電纜的阻燃等級；4+1芯電纜數據可安全用于3+2芯電纜。16mm2的電纜為5等芯。3.3.1計算敷設電纜所需長度時候，應留有適當余量附加長度，計算方法可參考表14鋁合金電纜近似直徑表導體截面STABILOY-AC90近似外徑(mm)STABILOY-ACWU90近似外徑(mm)STABILY-TC90近似外徑(mm)(mm2)3+1芯4芯4+1芯3+2芯3+1芯4芯4+1芯3+2芯3+1芯4芯4+1芯3+2芯20.621.6-23.3--25.224.825.8-27.5--29.320.8-22.5--24.42523.324.525.926.628.227.528.827.628.730.130.932.631.833.822.623.825.125.827.426.728.03525.326.727.829.030.429.331.529.631.032.234.035.033.836.724.625.927.028.229.628.530.85028.129.731.132.434.233.035.333.134.836.237.639.638.340.827.428.930.431.834.232.435.47031.733.635.036.738.837.140.436.938.940.442.244.442.646.131.033.535.036.938.937.340.69534.937.239.040.845.141.446.740.342.844.746.651.047.252.935.137.239.141.043.541.645.238.340.744.946.649.547.951.043.946.550.852.856.454.758.038.540.943.345.148.246.549.843.746.348.250.753.750.956.149.752.555.057.860.457.963.021.842.144.846.849.652.249.755.348.751.754.257.360.057.362.855.658.760.864.167.064.170.124.447.350.552.656.459.356.462.424054.358.260.364.067.063.770.461.665.167.371.374.970.978.627.453.857.459.663.666.763.270.430058.963.265.669.672.969.376.666.470.473.077.781.277.485.229.858.862.765.269.573.069.277.540065.169.972.777.180.977.185.073.278.181.185.889.885.794.233.765.669.972.978.182.178.086.550073.078.481.586.690.986.695.682.287.190.495.8100.495.8105.537.874.679.482.788.192.788.197.8表15鋁合金電纜穿管直徑表STBAILOY-TC90穿管管徑(mm)STABILOY-ACWU90穿管管徑(mm)彎曲數012012導體截面2)4芯4芯4芯4芯4芯4芯5050505050705050507070702550505070707050507070708035505070707080505070708050505070708070707080707070808070708095707080708070808080