環氧抗靜電地坪面漆的用途和數據說明.doc

環氧抗靜電地坪面漆的用途和數據說明Intended Uses用途用于具有抗靜電要求的水泥，混凝土地板和壁墻表面涂裝、如電子電器、印刷、紡織等廠車間、電器控制室，計算機房等。Suited for the floor or wall requiring anti-explosive coating. Such as electric factory, control room, compnter room, printing factory, textile miss etc.ProductInformation產品簡介高固體份厚膜型環氧地坪涂料，雙組份，漆膜耐磨，抗靜電，啞光或高光，有限顏色。High solid and high build epoxy floor paint, Two components with abrasion resistance, anti-static property semi-gloss or high gloss.Application details產品數據Volume Solids 體積固體份60%, Color 顏色Grey, green, blue, red and yellow etc灰、綠、藍、紅、黃等有限顏色Dry Flm Thickness干膜厚度50-200m , according to the surface conditions50-200m ,視表面狀況而定Theoretical Coverage 理論涂布率4.4-5.2 m2/kg at 100um of dry film thickness4.4-5.2平方米/公斤，以100微米干膜厚計以1mm干膜計時，為0.6-0.7 m2/kg （1.4-1.5 m2/kg ） Practical Coverage 實際涂布率Allow appropriate loss 允許適量損耗Storage and Handling施工詳述Mix Radio 混合比A : B=5:1(by weight) 甲:乙=5:1Method of Application 施工方法 Airless Spray 無空氣噴涂 Recommended 推薦采用 Brush or Roller 刷涂或輥涂 Recommended 推薦采用Air Spray 有空氣噴涂 Suitable, but diluting 10-20% is necessary 適用，但需稀釋10-20%Thinner 稀釋劑 C003Cleaner 油漆設備清洗劑 C003Pot Life 使用期 35：2hours; 25:4hours; 15:6hours 35：2小時; 25:4小時; 15:6小時 Storage 貯存期 one year 一年Drying time 干燥時間SubstrateTemperature底材溫度Touch Dry表干（h）Hard Dry硬干(h）Fully curing完全固化 （d）3525152461224363days 天5ays 天7days 天StorageandHandling貯存與管理Storage 貯存 Store in cool and dry conditions 貯存于陰涼干燥處 Pack size 包裝規格 A;20Kg in 20 liter container 甲:20公斤裝于20公升容器中 B:4 Kg in 4 liter container 乙:4公斤裝于4公升容器中Flash Point 閃點 33 （Mixture, A, B） 33 (混合物、甲組份、乙組份) Specific Gravity 比重 1.15-1.35 Kg/L 1.15-1.35公斤/公升Specification and Surface preparation技術要求及表面處理All cracks, joint intersections, protrydent and hollow spots the floor have been prepared correctly and the floor has applied with primer sealer and paved with conductive copper film connecting ground,or other conducting coatings (such as conducting spackler or conducting interdiate coating) . Thus the surface must be for good effect.This product cannot cure fully at low temperature. The substrate temperature should be maintained above 10 for good effect.在涂覆本產品前，地板上所有裂紋、接縫、凸起、凹陷、均已正確處理，涂裝了封閉底漆并已鋪設了導電銅鉑接地，也可在其他導電涂層上涂裝（如導電膩子或?qū)щ娭型酒幔?，確保地面和清潔干燥。本產品在低溫條件下無法充分固化，為求最佳效果，底材溫度應在10. 使用本產品，應現用現配，用多少配多少，并充分攪拌均勻，在使用期內用完，以免凝膠浪費。涂裝此涂料，初步干燥后，即可上人，完全固化后，才能投入使用。Safety Precautions安全措施This product should be used in painting area by perfessional operators. When painting , please refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying this product.參考 This product is a kind of solvent-based paint .Inorder to avoid danger or accident, minimal safety precautions,as follow , should be down .The paint contains volatile solvent and is flammable . So must keep away from sparks and open flames.No smoking at applacation site ,Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid producting sparks .Flash point of paint , mentioned above on product Data sheet, is the lowest temperature at which mixture of the volatile materails of paint can ignite or explode with air. Enough ventilation is necessary at application site. In order to remove any danger of explosion, must keep the ratio of gas to air is less than 10%, the minimum explosive limit in general, Therefore, 200m3of ventilation quantuty per 1Kg solvent (according to the solvent ) is necessary.Product skin and eyes, and avoid touching with paints (Recommend to wear working clothes, gloves,eye protection, face masks barrier cream and so on ). Kif paint gets in touch with skin , wass fully with large amount of fresh water and soap or appropriate commercial cleaner. In case of eyes being contaminated, rinse with fresh water for 10min at least and give medical treatment immediately. Recommend face guard with ventilation pipe for the sake of no absorption of paint fog and harmful solvent gas, especially in bad ventilation.Handle empty containers with care and do not bring about environmental contamination.NOTICE: If consumers have not taken effective safety precautions(Refer to the specfications), our company will NOTbe responsible for any accident. 本產品由專業人緣在工業場所使用,使用時請參照本說明書及健康安全手冊,如客戶在使用本產品前,未能仔細了解有關產品的健康安全知識,請與本公司聯系.該涂料為溶劑型涂料,為避免事故或危險發生,應采取最低限度的安全措施如下:此涂料為易燃物,并含有揮發性易燃溶劑,故必須遠離火星和明火,嚴禁在作業場所吸煙,并采取有效措施,防止火星產生(如采用防爆電器設備,杜絕靜電積累,避免金屬撞擊等)本產品說明書中所列涂料及溶劑的閃點是引起燃燒的最低溫度. 施工場所應盡量進行通風良好,為消除使用過程中的爆炸隱患,應保證足夠的通風量以維持氣體/空氣比例不超過最低爆炸極限的10%,通常每千克溶劑需要200立方米通風量,(與溶劑種類相關)