氯化橡膠中涂漆面漆.doc

氯化橡膠中涂漆/面漆Intended Uses用途氯化橡膠漆，設計用于噴漆施工，其用途包括：用于中度惡劣環境下的鋼材保護涂料，內墻和天花板保護涂料，具有抗均性和部分耐化學品性，可低溫涂裝。Chlorinated rubber paint. designed for spray application. Its use covers: protective paint for steel, interior wall and ceiling under moderately abominable conditions. This product posesed fungus resistance to some chemicals can be applied at low temperature. ProductDescription產品簡介單罐裝,厚膜型氯化橡膠漆，用作中涂漆或面漆，無空氣噴涂施工One package, high-build chlorinated rubber paint, used as intermediate coat or finish, Airless sprayProductInformation產品數據Volume Solids 固體份45%Dry Film Thickness干膜厚度50microns 50微米Theoretical Coverage 理論涂布率7.5m2 /Kg 7.5平方米/公斤Practical Coverage 實際涂布率Allow appropriate loss 允許適量損耗Application Details施工詳述Mix Radio 混合比One pack 單罐裝Method of Application 施工方法 Airless Spray 無空氣噴涂 Recommended 推薦采用 Brush or Roller 涂刷或輥涂 Recommended 推薦采用 Conventional Spray 傳統噴涂 Not Recommended 不推薦使用 Thinner 稀釋劑 C001Cleaner 油漆設備清洗劑 C001Pot Life 使用期 Not limit 不限制Storage 貯存期 One year 一年Drying time 干燥時間SubstrateTemperature底材溫度Touch Dry表干（H）Hard Dry硬干(H）Over coating Interval覆涂間隔Mix最短Max最長52335 2 1 0.524888 hour 小時4 hour 小時2 hour 小時Indefinite 不定Storage andHandling貯存與管理Storage 貯存 Store in cool and dry conditions 貯存于陰涼干燥處Pack size 包裝規格 A;25Kg in 20 liter container 甲:25公斤裝于20公升容器中Flash Point 閃點 23 高于23Specific Gravity 比重 Approx1.2Kg/L 大約1.2公斤/公升Specification and Surface preparation技術要求及表面處理Iron: Sand blasting to clean the standard Sa2.5 Sweden SIS055900. Pre-coated steel primer (at the venue recoating) grinding wheel to power a small area of the rust of the wash in addition to all of the soluble salt, and rust removed the edge of the area if the rust, and need a comprehensive sweep of sand, has been pre - James just paint the surface must be clean (such as gypsum, cement, etc.: reusable primer coating applied to the appropriate base on the other, but the paint surface must be clean, dry, dirt-free.鐵：噴砂清潔至 Sa2.5瑞典標準 SIS055900。預涂底漆鋼材（在場內預涂）以動力轉盤打磨小面積的生銹部分，洗除所有的可溶鹽份，并磨平生銹邊緣，如果生銹面積大，需全面掃砂，已預涂剛才，底漆表面必須清潔（如石膏、水泥等：可復涂於有適當涂裝底漆的其他底材上，但漆表面必須清潔、干燥、無污物。Limitations限制Unable to resist solvent, grease or fat. It is thermoplastic apt to soften and decompose above 80。不耐溶劑，油脂和脂肪，熱塑性。在80攝氏度以上易傾向軟化和分解。Safety Precautions 安全措施The product must be used in painting area by professionals. When painting, please be sure to refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying the product.The product is a kind of solvent-based paint. In order to avoid the accident or dangerous occurrence, minimal safety precaution, as follow, should be down.The paint contains volatile solvent and it is flammable, So must keep away from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid product sparks. Enough ventilation is necessary at application sites. In order to remove any danger of explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg solvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin and eye contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If accidental skin contact with the product, please use fresh water and soap or an appropriate industrial cleaning agents thoroughly cleansed. In case of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended to wear face shields to prevent inhalation of paint mist and harmful gases.Especially in poorly ventilated environment, it is more necessary.Finally, be handled with care so as not to waste paint barrels of pollution of the environment.NOTICE: If consumers have not taken effective safety precautions (Refer to the specification), our company will NOT be responsible for any accident. 本產品必須由專業人員在工業場所使用。使用時請務必參照本說明書以及相關健康安全手冊。若客戶在使用本產品前,未能詳細了解本產品的相關健康安全知識,請與本公司人員聯系。該涂料為溶劑型涂料，為避免事故或危險發生，應采取最低限度的安全措施如下：此涂料為易燃物,并含有揮發性易燃溶劑，故必須遠離火星和明火。嚴禁在作業場所吸煙，并應該采取有效措施，防止火星產生(如采用防爆電器設備，杜絕靜電積累,避免金屬撞擊等)。施工場所應盡量保持良好通風。為消除使用過程中的爆