YC橡套電纜技術參數

1、YC橡套電纜技術參數型號芯數X平方mmkg/kmA規格電纜外徑理論重量載流量YC2X 12 X 1.52 X 2.511.12165.84202X 412.82227.29262X 614.40293.87332X 1019.52575.35472X 1623.00768.09622X 2527.801110.39842X 3532.181488.801002X 5037.281997.121252X 7042.242621.531602X 9546.703328.672002 X 120230YC3X 13 X 1.53 X 2.511.91216.21163X 413.73300.1721

2、3X 615.40397.17283X 1020.95763.38393X 1624.001023.08533X 2529.791490.06733X 3534.461974.22913X 5030.872702.181103X 7045.183570.461403X 9550.134580.421803 X 12054.505603.61210YC3 X 1.5+1 X 13X 2.5+1 X 1.512.92261.53163 X 4+1 X 2.514.68355.07313X 6+1 X 416.6476.63383 X 10+1 X 621.2797.18393 X 16+1 X 6

3、24.961110.26533 X 25+1X 1030.671628.45733 X 35+1X 1034.092090.33913 X 50+1X 1640.893018.411103 X 70+1X 2546.133864.721403 X 95+1X 3550.584957.481803X 120+1 X 3553.755869.51310用途:本產品用于交流額定電壓 Uo/U 450/750V及以下動 力，家用電器及各種移動或電氣設備和工具用。二、性能：（一）通用橡套軟電纜：1 產品依據 GB5023-1997 及 JB8735-1998 標準。2、 電纜長期允許工作溫度應不超過65

4、C;3、W型派生電纜具有耐氣候和一定的耐油性能， 適 宜于在戶外或接觸油污的場合使用；4、成品電纜應經受下表規定的電壓實驗。實驗條件單位額定電壓V300/300 300/500450/750試樣長度m整卷整卷溫度C室溫室溫實驗電壓v20002500電壓施加時間min55（二）電焊機電纜:1產品依據GB5023-1997標準;2、電纜的長期允許工作溫度應不超過65 C;3、成品電纜應經受表A規定的交流50Hz浸水電壓實驗;4、成品電纜應經受表B規定的交流50Hz浸水電壓實驗;5、成品電纜應經受表C規定的靜態曲線實驗表A護套厚度 S mm試驗電壓V2.060002.0 V3.070002.5 V3

5、.08000實驗條件單位性能要求試樣長度最小m10浸水時間最小h1水溫C20試驗電壓值v2000施加電壓時間最小min5表C標稱截面mm2最大距離Lem標稱截面mm2最大距離Lem1045705516459560254512065355015070505018575（三）橡套電纜的型號名稱型號名稱用途YQ ,YQW輕型橡套軟電纜用于各種移動電器設備及工具YZ,YZW中型橡套軟電纜YC ,YCW重型橡套軟電纜YH天然膠護套電焊機電纜用于連接電焊機及焊鉗電纜YHF氯丁膠或其他相當?shù)暮铣赡z彈性護套電焊機電纜橡套電纜的生產范圍:型號額定電壓芯數標稱截面mm2YQ YQW300/5002、30.3-0.

6、5YZ YZW450/7502、3、4、50.75-6YC YCW450/75011.5-40021.5-953、41.5-10551.5-253.0 3.510000表B3.0 5 3.510000YH YHW200110-120注：根據用戶需要，還可生產以上規格外的產品（四）通用橡套軟電纜長期允許載流量?導線工作溫度：65 C環境溫度：25 C導線截面mm2空氣敷設長期允許載流量 AYQ、YQWYZ、YZWYC、 YCW心二心1 .二芯、1 三芯四芯一芯芯二心四芯0.3760.5119121090.75141214121111714131.521181822622222.530252537

7、30262744135364739343465345455251434410757463631611298848425148135115116351831671421435022620817617770289259224224953533182732731204153713163160.6/126/35kV 塑料絕緣高阻燃（隔氧層）電力電纜Plastic In sulated High Performa nee Flame-retarda nt Power Cable產品標準Standard本產品按GB12706-91額定電壓35KV及以下銅芯、鋁芯塑料絕緣電力電纜、GB12666.5-90標

8、準生產0.6/1kv26/35kvIEC、英國標準、德國標準、GB12666.5-90、電線電纜成束燃燒試驗、GB/T17650-1998取自電纜或光纜的材料燃燒時釋岀氣體的試驗方法和GB/T17651-1998電纜或光纜在特定條件下燃燒的煙密度測定 塑料絕緣電力電纜， 同時還可根據用戶需要按國際電工委員會推薦標準 及美國標準生產The product is manufaetured according to the standard of GB12706-91GB/T17650-1998 and GB/T17651-1998 or IEC and DIN and ICEA.適用范圍Appli

9、cations本產品適用于工頻額定電壓0.6/1kv26/35KV輸配電線路作配送電能之用。The product is suitable for power transmissionand distributionlines with rated voltage0.6/1kv26/35kv.使用特性 Operating characteristics .工頻額定電壓 U0/U為0.6/1kv26/35kv.Rated power freque ncy voltage Uo/U:0.6/1KV26/35KV.PVC絕緣電纜導體的長期最高工作溫度為70C。XLPE絕緣電纜導體的長期允許最高工作溫

10、度為90CPVC in sulated power cable Max . permissible con ti nuous operati ng temperature of thecon ductor should not exceed 70C ,XPLE permissible con ti nuous operat ing temperature ofthe con ductor should not exceed 90 C.短路時(最長持續時間不超過5s)電纜導體的最高溫度不超過250Max Short circurrt temperature of con ductor shall

11、 n ot exceed 250.(5s maximumdurati on) 電纜敷設時環境溫度不低于0CThe in stallati on temperature should not below 0C電纜阻燃性能滿足 GB12666.5-90標準A類相應指標要求。The flame-ratardantproperties of cable comply with the requirements specified in A kindof GB12666.5-90低鹵電纜除應滿足GB12666.5-90標準中A類相應指標要求外，還應滿足GB/T17650.1-1998標準規定的相應指標。

12、The flame-retardantproperties of lower halogen cable comply with requirementsspecifiedin A kind of GB12666.5-90 except compluing with requirements specified inGB/T17650.2-1998 .GB/T17650.2-1998無鹵電纜除應滿足 GB12666.5-90標準中A類相應指標要求外，還應滿足 和 GB/T17651-1998 標準規定的相應指標。The flame-retardant properties of no halo

13、gen cable comply with requirements specified in A kind of GB12666.5-90 except compluing with requirements specified in GB/T17650.2-1998 .and GB/T17651-1998.電纜彎曲半徑：三芯電纜不小于電纜外徑 15 倍；單芯電纜不小于電纜外徑 20 倍。Three bending radius of a single core should not less than 20 times of the cable diameter Two bending r

14、adius of a three-core cable should not less than 15 times of the cable diameter.電纜額定電壓的選擇 Voltage designation電纜額定電壓應適合于電纜的系統的運行狀況，用Uo/U ( U)表示，均為有效值，單位為kvU0- 電纜設計用導體與屏蔽或金屬套之間的額定工作電壓；U電纜設計用導體之間的額定工頻電壓；U -設備可承受的“最高系統”電壓的最大值。The rated voltage of the cable for a given application shall be suitable for t

15、he operating condition in the system in which the cable is used , and is expressed in the form of U0/U( Um) are applied to the system voltages and running state , and expressed in the formU0/Ukv.U0-The rated power-frequency voltage between conductor and earth or metallic screen ,for which the cable

16、designed .U-The rated power freque ncy voltage betwee n con ductors for which the cable desig ned.U- - The maximum value of“the highest system voltage ” for which the equipment may beused.三相系統用電纜的Ub值推薦如下表：The values U 0 recommended for cables to be used in three-phase systems are listed below:第一類一一用

17、于單相接地故障時間每一次一般不大于1min，亦可用于最長不超過8小時，每年累計不超過 125 小時的系統。 第二類用于接地故障時間更長的系統及對電纜絕緣性能要求較高的場合。The first class cable suitable for one single phase earthing block timedoes notexceed one minute each time. Max. time not exceed 8 hours ,and not exceed 125 hours in all in one year.The sec ond class cable suitable

18、 for more the earthi ng block time and more betterin sulated performa.電纜的型號 Type of cable0.6/1kv高阻燃（隔氧層）電纜的生產范圍retarda nt cableProducti on Range of high performa nee flame1.8/326/35kv 高阻燃（隔氧層）電纜的生產范圍Producti on Range of high performa nee flame- retarda nt cable型號Type電壓 Rated voltage kv芯數3.6/66/108.7

19、/1518/30辛呂芯Aluminum1.8/3銅芯 Copper conductorconductorcores6/68.7/1012/2026/35標稱截面 Nominal Cross-section Mm 2GZR-YJVGZR-YJLVGZR-DL(WL)-YJVGZR-DL(WL)-YJLV1063025630256303563035630GZR-YJV22GZR-YJLV2211063025630256303563035630GZR-DL(WL)-YJV22GZR-DL(WL)-YJLV221063025630256303563035630GZR-YJV32GZR-YJLV32GZ

20、R-DL(WL)-YJV32GZR-DL(WL)-YJLV32GZR-YJVGZR-YJLVGZR-DL(WL)-YJVGZR-DL(WL)-YJLV1050025500255003550035500GZR-YJV 22GZR-YJLV 2231050025500255003550035500GZR-DL(WL)-YJV22GZR-DL(WL)-YJLV221050025500255003550035500GZR-YJV 32GZR-YJLV 32GZR-DL(WL)-YJV32GZR-DL(WL)-YJLV32注：單芯鎧裝型高阻燃（隔氧層）電纜僅用于直流系統，應采用非磁性材料的鎧裝層或采用隔

21、磁措施。Note: The sin gle-core armoured high performa nee flame-retarda nt cables are used for d.c system only, as for a . c. system non-mag netic aromour materials should be or magn etic isolati on should be applied.電纜結構圖umh |,I-th,艷緣 In&ulalian隔堿上t Se|?Hr削I口 一 oxygen電r包帶ape夕Hf1 fcj4呻山電纜主要技術參數Main tech

22、 nical data of cable20C 時導體最大直流電阻Max.D.C resista nee of con ductor at 20C電壓試驗、局部放電試驗 Voltage test and partial discharge導體短路電流 Short - circuit current電容、電感(參考值) Capacitance and inductance of cable (reference value) 電容 Capacitance單芯電纜電感 Inductance of single core cable三芯電纜電感 Inductance of three cores cable電流載流量 The current carrying capacity0.6/1kv 聚氯乙烯絕緣電力電纜 0.6/1kv PVC insulated power cable (A)在土壤中的敷設 Buried (A)0.6/1KV 交聯聚氯乙烯絕緣非鎧裝型電力電纜 0.6/1kv XPLE insulated unarmoured power cable (A)0.6/1KV 交聯聚乙烯絕緣鎧裝型電力電纜 0.6/1kv XLPE insulated armoured power cable (A)3