安全帶專項培訓教材

1、安全帶專項安全教育培訓基礎知識培訓安全帶 Basic awareness training-safety harness 基礎知識培訓安全帶 Basic awareness training-safety harness設備/EQUIPMENT全身式安全帶/ Full Body HarnessFull-body harness全身式安全帶基礎知識培訓安全帶 Basic awareness training-safety harness設備/EQUIPMENT安全繩/緩沖器/Lanyard with Shock AbsorberShock absorber緩沖器Lanyard安全繩基礎知識培訓安

2、全帶 Basic awareness training-safety harness設備EQUIPMENT鋼環和彈簧大鉤/Karabiners and Snap HooksSnap Hooks彈 簧 大 鉤Karabiners鋼環使用前安全帶檢查 safety harness inspection 每次使用前，你必須檢查：INSPECT EACH TIME BEFORE USE:目測檢查： Visual inspection 安全帶 Straps不要太緊或太松 not too tight or too loose (snug)安全帶本身無扭曲,無打節或切割痕跡 no twist, knots

3、or cuts IN STRAPS無臨時修補 no temporary repairs 使用前安全帶檢查 safety harness inspection 每次使用前，你必須檢查：INSPECT EACH TIME BEFORE USE: 安全繩 Lanyard無繩節,切割或捻接 no knots, cuts or mid-line splices其長度和強度 suitable size and strength無磨損或化學物品的侵蝕 free from abrasive or chemical attack 配有緩沖器 shock absorber attached 怎樣佩戴安全帶 How

4、 to wear harness 怎樣佩戴安全帶 How to wear harness 怎樣佩戴安全帶 How to wear harness適當調節至舒適,合身之狀態 Correct tension and adjustment 為什么要佩戴全身式安全帶？ Why full-body harness required?墜落時能夠承受最大的沖擊力Forces imposed by A fall安全帶正確使用固定點 Proper anchorage-safety harness安全帶系掛要點 ANCHORAGE能承受足夠的強度 Adequate strength 扶手和管線 Handrails

5、 & pipework腳手架鋼管 Scaffold tube盡量高掛 Attach as high as possible嚴禁將安全帶系掛在：機械設備,障礙物,電纜或銳邊/角. DO NOT INSTALL ON：Machinery, obstructions, power cables,sharp edges.不正確的固定Incorrect Anchorage Points正確的固定Correct Anchorage Points使 用 須 知Safety Harness User佩戴時確信：To ensure:嚴禁將安全繩穿越腿與臂部間 Do not let lanyard pass be

6、tween legs / arms確信對他人無危險 Be aware of hazard to other workers 安全繩不在使用時,謹防隨地拖拉 Ensure lanyard is secured when not in use嚴禁作業面離安全帶掛靠點太遠（注意來回?cái)[動的幅度） Do not work too far from anchorage (Be aware of pendulum swing)攀爬時,確保人體擁有三個接觸點 Maintain 3-point contact when unclipping / re-clipping當高度少于四米時,不需要緩沖器Shock a

7、bsorber not required if less than 4m fall-distance 因?yàn)椋?Because:安全繩長： Lanyard distance: 1.5m緩沖器： Shock absorber: 1 m身高： Worker: 1.5m總高度： Total: 4 m國標規定：4米緩沖距離內，應不超過8825.4N。跌落到地上Hit the ground墜落載荷作用于減震器每條安全繩都有牢固的連接點減震器展開減緩沖擊墜落發生時安全繩受力作用于減震器-98第二根安全繩掛在D型環上第二根安全繩纏繞在身體上系索的不正確使用會導致危險Lanyards apply stress

8、across the stitching of shock absorber安全繩橫向施壓于緩沖器的接口處。Stitching fails due to load applied at right angles to designed load direction由于接口處受力與設計載荷方向成直角，接口斷開。Fall NOT arrested!墜落不能避免 安全帶的保養Care of Equipment安全帶配件 HARDWARE合適的尺寸和強度 suitable size and strength無扭曲,彎曲或裂紋 no twist, bends or cracks無臨時修補 no temp

9、orary repairs配件和固定件 DEVICES and ANCHORAGES處于良好的工作狀態 in good working condition合適的尺寸/強度 suitable size / strength 安全帶的保養Care of Equipment無化學物品的腐蝕 free from chemical attack清洗保養 Clean使用肥皂/水進行清洗 Clean with soap / water涼干,嚴禁將其置于強烈的太陽光下暴曬 Air dry equipment, dont hang in direct sunlight將其存放于陰涼,干燥,通風的地方 Store equipment in a cool, dark, dry well ventilated placeSAFETY HARNESS USER切記: A REMINDER 安全帶牢固程度完全 取決其最薄弱環節. 任何損壞,磨損,有墜 落隱患之設備必須清 除出施工現場. Your fall protection device