無機保溫砂漿外墻保溫工程施工方案【最新】

1、xr無 機 保 溫 砂 漿 外 墻 保 溫 工 程施工方 案 編制：無錫臣功節能材料有限責任公司 施工：無錫市馬山建筑工程有限公司 目 錄1、 編制依據2、 工程概況、系統基本構造與描述3、 施工部署4、 施工前準備工作5、 外保溫施工條件6、 材料配制7、 施工工藝流程及要點8、 工程質量控制及驗收9、 成品保護及安全注意事項10、 安全文明施工11、 現場材料管理1、 編制依據1、 工程合同、施工圖紙2、 建筑工程施工質量驗收統一標準(gb50300-2001)3、 建筑裝飾裝修工程質量驗收標準（gb50210-2001）4、 江蘇省建筑節能標準（dgj32j19-2007)5、 建筑節能

2、工程施工質量驗收規范（gb50411-2007）6、 外墻外保溫工程技術規程（jgj144-2004)2、 工程概況、系統基本構造與描述1、 工程概況：拆遷企業安置用房4#房項目，以下稱為本工程，由無錫雙盛石化裝備有限公司建設，無錫市馬山建筑工程有限公司施工，無錫輕大建筑設計研究院設計，無錫中寧建設咨詢有限公司監理，建筑面積為6152平方，層次為車間一層，辦公五層，辦公部分外墻設計為xr無機保溫材料，厚度為30。2、 無機保溫體系基本構造如下 3、 xr無機保溫的體系描述3.1概述：該材料利用酸性晶格體和xr植物蛋白膠，對膨脹珍珠巖進行改性，解決膨脹珍珠巖的易碎性和吸水率大的缺點，通過xr植物

3、蛋白膠的固化技術解決無機材料的粘接問題。xr無機保溫系統所用原材料均為無機材料（少量植物纖維除外），保溫系統穩定性高3、 施工部署項目經理 現場負責人 質檢員技術員安全員4、 施工前準備工作：1、 提供施工要求及技術交 底文件2、 建筑外墻部保溫層施工前，基層、外墻四角、洞口等處的表面平整及垂直度均應滿足有關施工驗收規范要求。3、 近垂直、水平方向 ，在墻角、陽臺樣板等處，彈好保溫層厚度控制線。4、 外墻外保溫施工過程 中如有施工要求的變化應發最短時間內出據書面洽商發使雙方及時更改減少損失5、 由于發包方及天氣異常及人工不可抗據的因素造成工期拖延應及時給予書面確認并相應調整施工計劃。6、 及時

4、解決施工用水、電、腳手架、工人宿舍等 必要條件，協助解決工人用餐問題7、 對已施工完成的部分及時分層驗收8、 協調各工種間的工序搭接，嚴防交差污染以保證外墻面的整體形象9、 常用的檢測工具有放線工具、托線板、方尺、鋼尺等。5、 外保溫施工條件1、 基層墻體應符合混凝土結構工程施工質量驗收規范（gb50204-2002）和砌體工程施工質量驗收規范（gb50203-2002）的要求，完成雨水管卡，設備洞口管道的安裝，安裝時要考慮保溫層的厚度，并將洞口四周圍用水泥砂漿抹平，所有的墻面需干燥。2、 墻面基層處理完畢，墻面應清理干凈，清掃浮灰等，外墻腳手要符合驗收規范。3、 要求現場提供有380伏、22

5、0伏電源4、 無機保溫砂漿和抗裂抹面砂漿應有好的保護包裝的破壞5、 操作地點環境和基底溫度不低于5度，風力不大于級5級，雨天不得施工。6、 材料配制1、 用界面劑的配制：按重量比配制，強度等級42.5的水泥：中砂：界面劑，按1：1：1，攪拌成均勻膏狀。2、 保溫資料的配制：粉料與水重量比1：1.8，先將水放入攪拌容器中，再將粉料加入，攪拌20分鐘使?jié){料成均勻膏狀。7、 施工工藝流程及要點（一）施工工藝流程材料準備配制界面劑配制xr無機保溫漿料基層墻體處理基層墻體涂刷界面劑吊垂直、套方、彈抹灰厚度控制線打點、沖筋抹第一遍xr無機保溫漿料抹第二遍xr無機保溫漿料保溫層驗收48小時后抹抗裂砂漿，同時

6、壓入網格布配制抗裂砂漿抗裂層驗收刮柔性膩?zhàn)域?yàn)收配制抗裂柔性膩?zhàn)?晾置干燥涂料飾面時（2） 、施工工藝說明1、 基層墻體處理清洗墻面2、 墻面沖筋根據保溫層厚度，將同等厚度的預制保溫板裁成30寬的小條，沿水平方向 每隔500粘貼，向上每隔1米一道水平筋，然后適當?shù)貨_一些豎筋，也可以用保溫漿料直接沖筋，以控制保溫層厚度。3、 抹保溫漿料保溫漿料要求分層操作，每次厚度1020，頭遍注意壓實，二遍注意壓實抹平，門窗洞口，陰陽角處應保證方正及垂直度，最少分二遍施工，兩遍相隔48小時以上，第一遍厚度大于第二遍，以距設計厚度相差10左右為宜。3、 抗裂砂漿的配制：強度等級42.5水泥：中砂：抗裂劑按1：3：

7、1重量比攪拌均勻，另加適量xr添加劑，配制抗裂砂漿，砂漿不得任意加水，應在4小時內用完。4、 抹抗裂砂漿、壓入玻纖網格布在保溫漿料上抹抗裂砂漿，厚度控制在3左右，用鐵抹子將網格布?jí)喝肟沽焉皾{內，網眼砂漿飽滿度要求到達100%，網格布搭接寬度不小于50，網格布邊緣嚴禁干搭接，必須嵌在抗裂砂漿中，陰角外網格布要壓搭接50，陽角處搭接200，搭接處網眼砂漿飽滿度兩層都要求達到100%，同時抹平，找直保持陰陽角處的方正及垂直。5、 做飾面涂料八、工程質量控制及驗收1、 施工檢測控制點1.1基層處理，要求墻面清洗干凈，無浮土，無油漬、空鼓及松動。1.2保溫砂漿漿料要求分層操作，每次厚度1020，要求達到

8、設計厚度，陰陽角、門窗洞口垂直、方正。. 2、 質量驗收標準（1） 主控項目 2.1所用材料品種、質量、性能應符合設計要求和本規程規定性能（材料檢測報告和出廠合格證）2.2保溫層厚及構造做法應符合建筑節能設計要求，保溫層厚度不允許有負偏差2.3保溫層與墻體以及各構造層之間必須粘接牢固，無脫層、空鼓及裂縫，面層無粉化、起皮和爆灰（2） 一般項目2.4表面平整、潔凈，接茬平整，線角和灰線平直方正，清晰美觀2.5孔洞、線槽、線盒、管道穿墻等 需要后處理的部位，應做到尺寸準確、邊緣整齊（3） 允許偏差及檢驗方法項次項 目允許偏差檢驗方法1立面垂直4用2m托線板檢查2表面平整4用2m靠尺及塞尺檢查3陰陽

9、角垂直4用2m托線板檢查4陰陽角方正4用20靠尺及塞尺檢查5保溫層厚度不允許有負偏差用探針，鋼尺檢查9、 成品保護及安全注意事項1、 門窗框外殘存砂漿應及時清理干凈，嚴禁蹬踩窗臺，防止損壞棱角2、 拆除架子時應輕拆輕放，防止撞壞門窗，墻面和洞口邊角等3、 保護好墻上的埋件、電纜槽、盒和預留孔洞等4、 嚴禁使用過時灰，各構造層硬化前禁止水沖，撞擊和擠壓5、 嚴禁在地面上直接配制xr無機保溫漿料和抗裂砂漿6、 施工人員應遵守安全規程，工人必須經過技術培訓和安全教育方可上崗。十、安全文明施工施工現場的科學化管理，將大大提高文明施工水平，加快工程進度，搞好材料節約，為了使我工地達到文明施工的標準，采取

10、以下措施：1、 施工現場成立安全組織 ，項目經理任組長，現場工長為副組長，并設置安全員，搞好安全交底，安全教育，嚴格執行安全規范的安全標準2、 進場施工人員必須戴安全帽，安全帶，不允許穿拖鞋，不允許在施工現場吸煙，遵守治安條例，不允許打架斗毆。3、 上外架之前，要認真檢查架子是否符合安全規范，堅決杜絕違章作業。11、 現場材料的管理1、 要設置專職材料員、對工程所用材料，強化質量認證制度，對不符合要求的材料堅決不可使用2、 做好材料的進出工作，并對施工部位的材料用量做嚴格的記錄3、 材料的包裝要及時回收，并注意材料的防竊，防水工作。employment tribunals sort out d

11、isagreements between employers and employees.you may need to make a claim to an employment tribunal if: you dont agree with the disciplinary action your employer has taken against you your employer dismisses you and you think that you have been dismissed unfairly.for more information about dismissal

12、 and unfair dismissal, seedismissal.you can make a claim to an employment tribunal, even if you haventappealedagainst the disciplinary action your employer has taken against you. however, if you win your case, the tribunal may reduce any compensation awarded to you as a result of your failure to app

13、eal.remember that in most cases you must make an application to an employment tribunal within three months of the date when the event you are complaining about happened. if your application is received after this time limit, the tribunal will not usually accept it.if you are worried about how the ti

14、me limits apply to you, take advice from one of the organisations listed underfurther help.employment tribunals are less formal than some other courts, but it is still a legal process and you will need to give evidence under an oath or affirmation.most people find making a claim to an employment tri

15、bunal challenging. if you are thinking about making a claim to an employment tribunal, you should get help straight away from one of the organisations listed underfurther help.if you are being represented by a solicitor at the tribunal, they may ask you to sign an agreement where you pay their fee o

16、ut of your compensation if you win the case. this is known as adamages-based agreement. in england and wales, your solicitor cant charge you more than 35% of your compensation if you win the case.if you are thinking about signing up for a damages-based agreement, you should make sure youre clear abo

17、ut the terms of the agreement. it might be best to get advice from an experienced adviser, for example, at a citizens advice bureau. to find your nearest cab, including those that give advice by e-mail, click onnearest cab.for more information about making a claim to an employment tribunal, seeemplo

18、yment tribunals.the (lack of) air up there watch mcayman islands-based webb, the head of fifas anti-racism taskforce, is in london for the football associations 150th anniversary celebrations and will attend citys premier league match at chelsea on sunday.i am going to be at the match tomorrow and i

19、 have asked to meet yaya toure, he told bbc sport.for me its about how he felt and i would like to speak to him first to find out what his experience was.uefa hasopened disciplinary proceedings against cskafor the racist behaviour of their fans duringcitys 2-1 win.michel platini, president of europe

20、an footballs governing body, has also ordered an immediate investigation into the referees actions.cska said they were surprised and disappointed by toures complaint. in a statement the russian side added: we found no racist insults from fans of cska.age has reached the end of the beginning of a wor

21、d. may be guilty in his seems to passing a lot of different life became the appearance of the same day; may be back in the past, to oneself the paranoid weird belief disillusionment, these days, my mind has been very messy, in my mind constantly. always feel oneself should go to do something, or wri

22、te something. twenty years of life trajectory deeply shallow, suddenly feel something, do it.一字開頭的年齡已經到了尾聲?；蛟S是愧疚于自己似乎把轉瞬即逝的很多個不同的日子過成了同一天的樣子；或許是追溯過去，對自己那些近乎偏執的怪異信念的醒悟，這些天以來，思緒一直很凌亂，在腦海中不斷糾纏。總覺得自己自己似乎應該去做點什么，或者寫點什么。二十年的人生軌跡深深淺淺，突然就感覺到有些事情，非做不可了。the end of our life, and can meet many things really do?

23、而窮盡我們的一生，又能遇到多少事情是真正地非做不可？during my childhood, think lucky money and new clothes are necessary for new year, but as the advance of the age, will be more and more found that those things are optional; junior high school, thought to have a crush on just means that the real growth, but over the past th

24、ree years later, his writing of alumni in peace, suddenly found that isnt really grow up, it seems is not so important; then in high school, think dont want to give vent to out your inner voice can be in the high school children of the feelings in a period, but was eventually infarction when graduat

25、ion party in the throat, later again stood on the pitch he has sweat profusely, looked at his thrown a basketball hoops, suddenly found himself has already cant remember his appearance.童年時，覺得壓歲錢和新衣服是過年必備，但是隨著年齡的推進，會越來越發現，那些東西根本就可有可無；初中時，以為要有一場暗戀才意味著真正的成長，但三年過去后，自己心平氣和的寫同學錄的時候，突然就發現是不是真正的成長了，好像并沒有那么重

26、要了；然后到了高中，覺得非要吐露出自己的心聲才能為高中生涯里的懵懂情愫劃上一個句點，但畢業晚會的時候最終還是被梗塞在了咽喉，后來再次站在他曾經揮汗如雨的球場，看著他投過籃球的球框時，突然間發現自己已經想不起他的容顏。originally, this world, can produce a chemical reaction to an event, in addition to resolutely, have to do, and time.原來，這個世界上，對某個事件能產生化學反應的，除了非做不可的堅決，還有，時間。a persons time, your ideas are alway

27、s special to clear. want, want, line is clear, as if nothing could shake his. also once seemed to be determined to do something, but more often is he backed out at last. dislike his cowardice, finally found that there are a lot of love, there are a lot of miss, like shadow really have been doomed. t

28、hose who do, just green years oneself give oneself an arm injection, or is a self-righteous spiritual.一個人的時候，自己的想法總是特別地清晰。想要的，不想要的，界限明確，好像沒有什么可以撼動自己。也曾經好像已經下定了決心去做某件事，但更多的時候是最后又打起了退堂鼓。嫌惡過自己的怯懦，最終卻發現有很多緣分，有很多錯過，好像冥冥之中真的已經注定。那些曾經所謂的非做不可，只是青蔥年華里自己給自己注射的一支強心劑，或者說，是自以為是的精神寄托罷了。at the moment, the sky is d

29、ark, the air is fresh factor after just rained. suddenly thought of blue plaid shirt; those were broken into various shapes of stationery; from the corner at the beginning of deep friendship; have declared the end of the encounter that havent start planning. those years, those days of do, finally, l

30、ike youth, will end in our life.此刻，天空是陰暗的，空氣里有著剛下過雨之后的清新因子。突然想到那件藍格子襯衫；那些被折成各種各樣形狀的信紙；那段從街角深巷伊始的友誼；還有那場還沒有開始就宣告了終結的邂逅計劃那些年那些天的非做不可，終于和青春一樣，都將在我們的人生中謝幕。baumgartner the disappointing news: mission aborted. r plays an important role in this mission. starting at the ground, conditions have to be very ca

31、lm - winds less than 2 mph, with no precipitation or humidity and limited cloud cover. the balloon, with capsule attached, will move through the lower level of the atmosphere (the troposphere) where our day-to-day weather lives. it will climb higher than the tip of mount everest (5.5 miles/8.85 kilo

32、meters), drifting even higher than the cruising altitude of commercial airliners (5.6 miles/9.17 kilometers) and into the stratosphere. as he crosses the boundary layer (called the tropopause),e can expect a lot of turbulence.the supersonic descent could happen as early as sunda.the weathethe balloo

33、n will slowly drift to the edge of space at 120,000 feet ( then, i would assume, he will slowly step out onto something resembling an olympic diving platform.below, the earth becomes the concrete bottom of a swimming pool that he wants to land on, but not too hard. still, hell be traveling fast, so despite the