環氧鐵紅車間底漆的使用方法

1、intended uses用途經拋丸或噴砂后的鋼材作保養底漆，保養期可達3-6個月，也可用鋼結構貯藏底漆使用，是一種常溫固化的車間底漆，干燥快，物理機械性能優良，能和各類底漆配套，由于不含金屬鋅等物質，故能減少焊接產生的氣體危害suited for steel shot or grit blasted shop primer with 3-6 months of maintenance period and for steel structure tank as primer as well. curing at ambient temperature. quick dry, excellen

2、t physical and mechanical properties. it is able to match with all the primer and may reduce harm of gas risen from electro-weding owing to no zinc etc in them productinformation產品簡介雙組分,鐵紅色tw opackages, iron redapplication details產品數據volume solids 固體份25%dry flm thickness干膜厚度25 microns equivalent to

3、100 microns of wet film25微米相當于100微米濕膜厚theoretical coverage 理論涂布率8.7m2 /kg 8.7平方米/公斤practical coverage 實際涂布率allow appropriate loss 允許適量損耗storage and handling施工詳述mix radio 混合比a : b=15:6.4(by weight) 甲:乙=15:6.4method of application 施工方法 airless spray 無空氣噴涂 recommended 推薦采用 brush or roller 涂刷或輥涂 recomme

4、nded 推薦采用 conwentional spray 傳統噴涂 not recommended 不推薦采用thinner 稀釋劑 sc006 maximum thining:5% 最大稀釋量：5% sc006cleaner 油漆設備清洗劑 scoo6pot life 使用期 2 5:24h 2 5約24小時storage 貯存期 one year 一年drying time 干燥時間substratetemperature底材溫度touch dry表干(min）hard dry硬干(h）over coating interval覆涂間隔min最短max最長2540.516 hours 小時

5、3months 3個月 環氧鐵紅車間底漆的使用方法 storageandhandling貯存與管理storage 貯存 store in cool and dry conditions 貯存于陰涼干燥處 pack size 包裝規格 a;15kg in 20 liter container 甲:15公斤裝于20公升容器中 b:6.4kg in 10 liter container 乙:6.4公斤裝10公升容器中flash point 閃點 5 specific gravity 比重 approx1.15kg/l 大約1.15公斤/公升specification and surface prep

6、aration技術要求及表面處 理steel surface to be painted should be blaseed to swedish standard sa2.5 or rust-removed manually or with power tool to st3.鋼材表面：噴砂處理至瑞典標準 sa2.5 級或動力工具除銹至 st3級limitations 限制 recommend coat: spary one coat with high-pressure airless spray for the purpose of reaching 20-25 microns of d

7、ry film thickness.subsequent coat: epoxy resin paint, coal-tar epoxy paint, chlorinated rubber paint, alkyd resin paint. phenolic resin paint, chlorosulphonated polythylene anticorrosive paint and rlighly chloronated polyeerylene anticorrosive paint etc.建議涂裝道數：高壓無空氣噴涂一道，干膜厚度達20-25微米后道配套涂料：環氧樹脂涂料、環氧瀝

8、青涂料、氯化橡膠涂料、醇酸樹脂涂料、酚醛樹脂涂料、氯磺化聚乙烯防腐涂料、高氯化聚乙烯防腐涂料。 safety precautions 安全措施this product should be used in painting area by perfessional operators. when painting , please refer to product data sheet and msds. consult our company if consumers could not completely understand the precautions for safety and

9、health when applying this product.this product is a kind of solvent-based paint .inorder to avoid danger or accident, minimal safety precautions,as follow , should be down .the paint contains volatile solvent and is flammable . so must keep away from sparks and open flames.no smoking at applacation

10、site ,effective precautions (such as using explosion-proof electrical equipments. no static electricity accumulation or metal collision etc) also should be done so as to avoid producting sparks .flash point of paint , mentioned above on product data sheet, is the lowest temperature at which mixture

11、of the volatile materails of paint can ignite or explode with air. enough ventilation is necessary at application site. in order to remove any danger of explosion, must keep the ratio of gas to air is less than 10%, the minimum explosive limit in general, therefore, 200m3 of ventilation quantuty per

12、 1kg solvent (according to the solvent ) is necessary.product skin and eyes, and avoid touching with paints (recommend to wear working clothes, gloves,eye protection, face masks barrier cream and so on ). kif paint gets in touch with skin , wass fully with large amount of fresh water and soap or app

13、ropriate commercial cleaner. in case of eyes being contaminated, rinse with fresh water for 10min at least and give medical treatment immediately. recommend face guard with ventilation pipe for the sake of no absorption of paint fog and harmful solvent gas, especially in bad ventilation.handle empty

14、 containers with care and do not bring about environmental contamination.notice: if consumers have not taken effective safety precautions(refer to the specfications), our company will notbe responsible for any accident. 本產品由專業人緣在工業場所使用,使用時請參照本說明書及健康安全手冊,如客戶在使用本產品前,未能仔細了解有關產品的健康安全知識,請與本公司聯系.該涂料為溶劑型涂料,為避免事故或危險發生,應采取最低限度的安全措施如下:此涂料為易燃物,并含有揮發性易燃溶劑,故必須遠離火星和明火,嚴禁在作業場所吸煙,并采取有效措施,防止火星產生(如采用防爆電器設備,杜絕靜電積累,避免金屬撞擊等)本產品說明書中所列涂料及溶劑的閃點是引起燃燒的最低溫度. 施工場所應盡量進行通風良好,為消除使用過程中的爆炸隱患,應保證足夠的通風量以維持氣體/空氣比例不超過最低爆炸極限的10%,通常每千克溶劑需要200