大體積混凝土測溫檢測報告

1、完整版本混凝土測溫檢測報告工程名稱/委托編號/委托單位/工程地點/建設單位/監理單位/施工單位/設計單位/檢測部位/檢測類別/檢測原因混凝土溫度監測檢測日期2013.07.02 檢測環境條件自然報告日期檢測依據大體積混凝土施工規范 GB50496-2009檢測結論本工程基礎承臺混凝土方量為 77m,測溫從2013年7月2日至2013年7月8 日，總計6天?；炷翂K體溫峰值在澆筑后13天出現，最高溫度值為69.0 C （測 溫點1中部）,平均入模溫度為35.9 C。各站點傳感器溫度值詳見附表1附表3, 各站點傳感器溫度曲線詳見附圖 2附圖4。從混凝土測溫值、溫度曲線及以上數 據結合現場實體進行分

2、析觀察可知：該基礎承臺混凝土澆筑體在入模溫度基礎上的 升溫值為33.1 T，溫升值不大于50 T ;混凝土澆筑塊體的里表溫差為 9.8 C,不 大于25C；混凝土澆筑體的最大降溫速率為 5.4 C /d ,根據GB50496-2009的要求， 混凝土澆筑體在入模溫度基礎上的溫升值差、混凝土澆筑塊體的里表溫差符合要 求；混凝土澆筑體的最大降溫速率、混凝土澆筑體表面與大氣溫不符合規范要求。 建議施工單位應及時做好保溫養護措施。備注/聲明1、報告未蓋檢測單位“檢測報告專用章”無效；2、復制報告未重新加蓋檢測單位“檢測報告專用章”無效；3、對報告若有異議，應于十五日內向檢測單位提出；4、有關檢測數據未

3、經允許，委托單位不得擅自向社會發布報告信息。批準:審核:校核:試驗:混凝土測溫檢測報告（附錄）、工程概況：受*委托對某項目的基礎承臺砼進行溫度監測，該基礎承臺混凝土厚度為1200mm二、檢測依據：大體積混凝土施工規范 GB50496-2009某工程施工圖三、檢測內容及檢測目的：檢測內容：基礎承臺混凝土內的溫度場分布。檢測目的：實時監測混凝土在施工和養護期間，沿承臺深度和寬度方向的混凝土溫度變化狀態，實行信息化控制，及時調整保溫及養護措施，使混凝土溫度梯度和溫度增值不 致過大，以有效控制有害裂縫的出現。四、檢測儀器設備：本次監測采用由濟* 公司生產的ADS版數據采集器4臺（編號：*）和傳感器。五

4、、溫控指標及報警線：根據GB 50496-2009的要求，本工程溫控指標為：1. 混凝土澆筑體在入模溫度基礎上的溫升值不宜大于50 C；2. 混凝土澆筑塊體的里表溫差（不含混凝土收縮的當量溫度）不宜大于25C；3. 混凝土澆筑體的降溫速率不宜大于 2.0 C；4. 混凝土澆筑體表面與大氣溫差不宜大于 20 C。六、測溫點布置本次監測在承臺平面共布置 3個平面測溫點位，每個平面測溫點位沿厚度分別布 置3個測溫點，詳見附圖1、附圖6。七、測溫記錄：本次測溫時間從2013年7月2日至2013年7月8日，總計6天，測溫間隔3小時， 各站點傳感器溫度值詳見附表1附表3,各站點傳感器溫度曲線詳見附圖 2附

5、圖4,環 境溫度測溫間隔3小時，環境溫度值詳見附表 4,環境溫度溫度曲線詳見附圖5。附表1-1數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2013-07-02 19:31135.8 C36.3 C35.0 C1.3 C2013-07-02 22:31136.9 °C38.2 C38.4 C1.5 C2013-07-03 01:32138.6 C40.7 C39.7 C2.1 C2013-07-03 04:33139.3 C42.0 C42.9 C3.6 C2013-07-03 07:34139.2 C44.8 C44.2 C5.6 C2013-07-03 10:34140

6、.5 C47.5 C46.3 C7.0 C2013-07-03 13:35141.9 C48.2 C47.7 C6.3 C2013-07-03 16:35142.2 C50.1 C50.7 C8.5 C2013-07-03 19:36144.2 C52.8 C52.8 C8.6 C2013-07-03 22:37147.1 C55.9 C53.6 C8.8 C2013-07-04 01:38148.4 C56.3 C56.9 C8.5 C2013-07-04 04:38150.7 C58.9 C58.8 C8.2 C2013-07-04 07:39154.4 C61.7 C59.1 C7.3

7、C2013-07-04 10:39158.0 C63.4 C61.8 C5.4 C2013-07-04 13:40161.4 C65.8 C64.6 C4.4 C2013-07-04 16:41163.7 C68.1 C65.4 C4.4 C2013-07-04 19:42163.0 C69.0 C66.7 C6.0 C2013-07-04 22:43161.5 C66.4 C64.5 C4.9 C2013-07-05 01:43161.1 C66.2 C63.9 C5.1 C2013-07-05 04:44160.2 C65.4 C63.2 C5.2 C2013-07-05 07:45159

8、.9 C64.8 C62.5 C4.9 C2013-07-05 10:45159.0 C64.0 C62.0 C5.0 C2013-07-05 13:46158.3 C63.6 C61.2 C5.3 C2013-07-05 16:46157.5 C62.7 C60.8 C5.2 C2013-07-05 19:47157.4 C62.1 C59.9 C4.7 C2013-07-05 22:48156.6 C61.7 C59.4 C5.1 C2013-07-06 01:48155.6 C60.9 C59.0 C5.3 C2013-07-06 04:49154.9 C60.1 C58.5 C5.2

9、C2013-07-06 07:50154.4 C59.8 C57.6 C5.4 C2013-07-06 10:51153.9 C58.6 C57.2 C4.7 C2013-07-06 13:51153.3 C58.1 C56.3 C4.8 C2013-07-06 16:52152.8 C57.3 C55.4 C4.5 C2013-07-06 19:53152.0 C57.0 C54.8 C5.0 C2013-07-06 22:54151.5 C56.6 C54.4 C5.1 C2013-07-07 01:55150.3 C55.8 C53.7 C5.5 C2013-07-07 04:56150

10、.2 C54.7 C53.1 C4.5 C2013-07-07 07:57149.2 C54.4 C52.2 C5.2 C2013-07-07 10:57148.5 C53.4 C51.5 C4.9 C2013-07-07 13:58148.3 C53.0 C51.2 C4.7 C2013-07-07 17:00147.7 C52.7 C50.3 C5.0 C數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2013-07-07 20:00146.9 °C51.5 C49.4 C4.6 C2013-07-07 23:01145.8 C51.2 C49.3 C5.4 C2013-

11、07-08 02:03145.6 C50.5 C48.6 C4.9 C2013-07-08 05:03145.1 C49.8 C48.1 C4.7 C2013-07-08 08:04143.9 C48.8 C46.8 C4.9 C本頁以下空白數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2013-07-02 19:31236.0 °C37.0 C36.2 C1.0 C2013-07-02 22:32238.4 C37.5 C38.3 C0.9 C2013-07-03 01:32237.7 C39.3 C40.8 C3.1 C2013-07-03 04:32239.7 C43

12、.2 C41.1 C3.5 C2013-07-03 07:33240.2 C44.5 C43.7 C4.3 C2013-07-03 10:34241.0 C46.8 C46.8 C5.8 C2013-07-03 13:34242.2 C48.3 C47.9 C6.1 C2013-07-03 16:35243.7 C50.0 C50.2 C6.5 C2013-07-03 19:35244.4 C52.0 C52.4 C8.0 C2013-07-03 22:37246.4 C54.8 C54.4 C8.4 C2013-07-04 01:37249.6 C56.7 C56.0 C7.1 C2013-

13、07-04 04:38250.4 C60.2 C58.0 C9.8 C2013-07-04 07:39253.8 C61.7 C59.7 C7.9 C2013-07-04 10:39257.6 C63.7 C62.5 C6.1 C2013-07-04 13:40260.5 C64.4 C63.9 C3.9 C2013-07-04 16:40262.7 C68.3 C65.5 C5.6 C2013-07-04 19:41263.0 C67.9 C65.6 C4.9 C2013-07-04 22:42261.8 C66.8 C65.0 C5.0 C2013-07-05 01:43260.8 C66

14、.1 C64.0 C5.3 C2013-07-05 04:43260.7 C65.5 C63.5 C4.8 C2013-07-05 07:44259.6 C64.5 C63.0 C4.9 C2013-07-05 10:46259.2 C63.9 C62.2 C4.7 C2013-07-05 13:46258.6 C63.7 C61.6 C5.1 C2013-07-05 16:47257.8 C62.9 C60.7 C5.1 C2013-07-05 19:47257.2 C61.8 C60.1 C4.6 C2013-07-05 22:48256.8 C61.4 C59.3 C4.6 C2013-

15、07-06 01:49256.1 C60.6 C58.7 C4.5 C2013-07-06 04:50255.3 C60.3 C58.4 C5.0 C2013-07-06 07:50254.7 C59.5 C57.7 C4.8 C2013-07-06 10:50253.8 C59.1 C56.7 C5.3 C2013-07-06 13:52253.3 C58.2 C56.5 C4.9 C2013-07-06 16:53252.7 C57.5 C55.5 C4.8 C2013-07-06 19:53252.1 C56.9 C55.1 C4.8 C2013-07-06 22:54251.3 C56

16、.6 C54.1 C5.3 C2013-07-07 01:55251.0 C55.4 C53.4 C4.4 C2013-07-07 04:55250.1 C55.2 C52.9 C5.1 C2013-07-07 07:57249.1 C54.6 C52.1 C5.5 C2013-07-07 10:57248.4 C53.8 C51.7 C5.4 C2013-07-07 13:58248.1 C53.2 C50.8 C5.1 C2013-07-07 16:58247.5 C52.3 C50.6 C4.8 C數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2013-07-07 19:582

17、46.4 °C51.8 C49.5 C5.4 C2013-07-07 22:59246.4 C51.1 C49.1 C4.7 C2013-07-08 02:00245.4 C50.3 C48.7 C4.9 C2013-07-08 05:00245.0 C50.0 C47.5 C5.0 C2013-07-08 08:02244.4 C48.9 C46.9 C4.5 C本頁以下空白數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2013-07-02 19:32335.6 °C36.4 C35.2 C1.2 C2013-07-02 22:32337.5 C37.3 C38

18、.8 C1.5 C2013-07-03 01:33337.9 C40.8 C39.4 C2.9 C2013-07-03 04:34338.4 C43.4 C42.0 C5.0 C2013-07-03 07:36339.2 C45.4 C44.0 C6.2 C2013-07-03 10:36341.7 C47.3 C45.4 C5.6 C2013-07-03 13:37342.2 C48.0 C48.9 C6.7 C2013-07-03 16:38342.7 C49.9 C49.1 C7.2 C2013-07-03 19:38345.5 C53.4 C52.9 C7.9 C2013-07-03

19、22:38346.8 C55.6 C54.9 C8.8 C2013-07-04 01:38348.1 C57.2 C56.3 C9.1 C2013-07-04 04:39350.2 C58.8 C57.3 C8.6 C2013-07-04 07:40354.6 C61.6 C59.6 C7.0 C2013-07-04 10:40357.3 C62.5 C61.1 C5.2 C2013-07-04 13:41361.2 C65.4 C63.2 C4.2 C2013-07-04 16:41363.5 C68.1 C66.6 C4.6 C2013-07-04 19:42362.6 C67.7 C66

20、.6 C5.1 C2013-07-04 22:42361.5 C66.8 C64.4 C5.3 C2013-07-05 01:43360.7 C65.9 C64.2 C5.2 C2013-07-05 04:43360.1 C65.5 C63.2 C5.4 C2013-07-05 07:43359.6 C65.0 C62.8 C5.4 C2013-07-05 10:44359.0 C64.3 C61.8 C5.3 C2013-07-05 13:45358.7 C63.2 C61.4 C4.5 C2013-07-05 16:46357.7 C62.8 C60.9 C5.1 C2013-07-05

21、19:47357.3 C62.4 C59.8 C5.1 C2013-07-05 22:48356.6 C61.4 C59.5 C4.8 C2013-07-06 01:48356.0 C60.7 C58.6 C4.7 C2013-07-06 04:49355.0 C60.1 C58.4 C5.1 C2013-07-06 07:50354.2 C59.6 C57.8 C5.4 C2013-07-06 10:50353.9 C59.1 C57.2 C5.2 C2013-07-06 13:50353.4 C58.1 C56.2 C4.7 C2013-07-06 16:51352.5 C57.7 C55

22、.8 C5.2 C2013-07-06 19:52352.1 C56.8 C55.2 C4.7 C2013-07-06 22:53351.5 C56.4 C54.3 C4.9 C2013-07-07 01:54350.7 C55.9 C53.6 C5.2 C2013-07-07 04:54349.7 C55.0 C52.7 C5.3 C2013-07-07 07:55349.3 C54.0 C52.1 C4.7 C2013-07-07 10:57348.5 C53.4 C52.0 C4.9 C2013-07-07 13:57348.0 C53.3 C50.9 C5.3 C2013-07-07

23、16:58347.3 C52.7 C50.5 C5.4 C數據接收時間站點號1#傳感器2#傳感器3#傳感器最大溫差2013-07-07 19:59347.0 °C51.5 C49.7 C4.5 C2013-07-07 22:59346.3 C51.1 C49.3 C4.8 C2013-07-08 02:01345.7 C50.6 C48.6 C4.9 C2013-07-08 05:02344.8 C50.1 C48.0 C5.3 C2013-07-08 08:03344.1 C49.2 C47.2 C5.1 C本頁以下空白溫度監測時間環境溫度溫度監測時間環境溫度溫度監測時間環境溫度2

24、013-7-2 19:3230.8 °C2013-7-5 7:5029.2 C2013-7-7 20:0333.2 C2013-7-2 22:3328.9 C2013-7-5 10:5132.8 C2013-7-7 23:0328.9 C2013-7-3 1:3427.3 C2013-7-5 13:5136.1 C2013-7-8 2:0427.9 C2013-7-3 4:3527.7 C2013-7-5 16:5234.9 C2013-7-8 5:0527.1 C2013-7-3 7:3629.8 C2013-7-5 19:5233.6 C2013-7-8 8:0629.1 C2013-7-3 10:3732.4 C2013-7-5 22:5328.0 C/2013-7-3 13:3936.8 C2013-7-6 1:5327.7 C/2013-7-3 16:4034.1 C2013-7-6 4:5428.0 C/2013-7-3 19:4033.7 C2013-7-6 7:5529.3 C/2013-7-