綜合實驗停留時間分布綜合實驗報告

1、停留時間分布綜合實驗報告停留時間分布綜合實驗一、實驗?zāi)康?. 掌握用脈沖示蹤法測定停留時間分布及數據處理方法；2. 了解和掌握停留時間分布函數的基本原理；3. 了解停留時間分布與模型參數的關系；4. 了解多級混本實驗通過單釜、多釜及管式反應器中停留時間分布的測定，將數據計算結果用多釜串聯模型來定量返混程度，從而認識限制返混的措施和釜、管式反應器特性；5. 了解和掌握模型參數N的物理意義及計算方法。二、實驗原理在連續流動反應器中，由于反應物料的返混以及在反應器內出現的層流，死角，短路等現象，使得反應物料在反應器中的停留時間有長有短，即形成停留時間分布，影響反應進程和最終結果。測定物料的停留時間分

2、布是描述物料在反應器內的流動特性和進行反應器設計計算的內容之一。停留時間分布可以用停留時間分布密度函數E(t)和停留時間分布函數F(t)來表示，這兩種概率分布之間存在著對應關系，本實驗只是用沖脈示蹤法來測定E(t),利用其對應關系也可以求出F(t)來。函數E(t)的定義是：在某一瞬間加入系統一定量示蹤物料，該物料中各流體粒子將經過不同的停留時間后依次流出，而停留時間在t,t+dt間的物料占全部示蹤物料的分率為E(t)dto根據定義E(t)有歸一化性質：E(t)dt='-0(1)E(t)可以用其他量表示為E(t)=(Q/M)c(t)(2)其中：Q0主流體體積流量，M為示蹤物量，c(t)為

3、t時刻流出的示蹤劑濃度。對停留時間分布密度函數E(t)有兩個重要概念，數學期望t和方差二3它們分別定義為E(t)對原點的一次矩和二次矩。當實驗數據的數量大，且所獲樣品是瞬間樣品，即相應于某時刻t下的樣品，貝、E(tj兀二'a】i=12'tiE(ti/：ti2i4rCAiM o i zlt 二-N(4)、E（t社-CAp“： ti式中 ti是兩次取樣時間,若等時間間隔取樣,G祎5CAi二CAi對恒容穩定流動系統有:二空_V。(6)有以下關系:(7)為了使用方便，常用對比時間一來代換t,經這樣變換后,TE(附二E(t)22%吁百(8)對全混流匚2口對活塞流匚2:0,對一般情況0:舄

4、一用無因次二2來評價反應器內的流動狀態比較方便，一般可將實際反應器當做多級串聯釜式反應器加以描述，并認為每級為全混流反應釜，各級存料量相等，級間無返混。對多級全混釜有（N為串聯全混釜的個數）：（9）三、實驗儀器、設備和試劑實驗儀器與設備：釜式反應器（兩個）、管式反應器（一個）、水泵（一個）、轉子流量計,閥門，管線若干，電導率儀三臺，分析天平；實驗試劑：飽和KCI溶液。四、實驗裝置原理圖51-槽；2磁力泵；3調節閥；4三通閥；5注射器；6、10、五、實驗安排5.1實驗內容1、安裝實驗裝置。2、測定不同濃度下KCI電導率的標準曲線（最大值為2mS。計算對示蹤劑注入量，并根據反應器體積計算KCI溶液

5、的濃度范圍是否在可測量范圍。3、 選擇合適的流量，將平均停留時間保持在10-20min,注入適量的示蹤劑，測定單釜不同時間的電導率值，繪制單釜停留時間與電導關系曲線，計算停留時間分布函數及停留時間分布密度函數。4、 選擇合適流量，將平均停留時間保持在10-20min,注入適量的示蹤劑，測定兩釜并聯條件下的電導率值，計算并繪制單釜及兩釜并聯的停留時間與電導關系曲線，計算停留時間分布函數及停留時間分布密度函數。5、按4進行兩釜串聯實驗。6、測定釜式、管式反應器串聯的停留時間分布曲線，并計算停留時間分布函數及密度分布函數。7、 大型智能儀器的操作使用，用其測量釜式反應器串聯的停留時間分布曲線，并計算

6、停留時間分布函數及密度分布函數。5. 2實驗安排時間實驗內容2015.11.2上午指導老師講解實驗原理，安排實驗時間，自行組裝實驗裝置；單釜不轉，水流量Q=4L/h,平均停留時間保持在20-40min,注入飽和KC1溶液示蹤劑2.0mL記錄單釜不同時間的電導率值；下午單釜中轉，水流量Q=46L/h,平均停留時間保持在20-40min,注入飽和KCI溶液示蹤劑2.0mL分別記錄單釜不同時間的電導率值；2013.11.3上午休息下午單釜、中轉，水流量Q=8L/h,平均停留時間保持在20-40niin,注入飽和KCI溶液示蹤劑2.0ml,記錄單釜在不同時間的電導率值；雙釜串聯、雙釜都不轉，水流量Q=

7、4L/h平均停留時間保持在20-40min,注入飽和KCI溶液示蹤劑2.0ml,記錄雙釜串聯在不同時間的電導率值；2013.11.4上午兩釜串聯、一釜中轉，一釜大轉，水流量Q=24、6L/h,平均停留時間保持在20-40min,注入飽和KC1溶液示蹤劑2.0ml,記錄雙釜串聯在不同時間的電導率值；下午兩釜并聯、一釜中轉，一釜大轉，水流量Q=24、6L/h,和兩釜不轉，水流量Q=4L/h平均停留時間保持在20-40min,注入飽和KC1溶液示蹤劑2.0ml,記錄雙釜并聯在不同時間的電導率值；2015.11.5上午休息下午管釜串聯，釜式反應器轉速中等。選定水的流量Q=4和6L/h。將平均停留時間保

8、持在20-40min,注入飽和KC1溶液示蹤劑2.0ml,記錄管釜串聯在不同時間的電導率值2015.11.6上午真實設備測量電導率確定停留時間下午處理實驗報告六、數據處理6. 1KCI電導率的標準曲線電導率(uS/cm)14.9473.9147717.81413276766681290C濃度(mol/L)0.00010.00050.0010.0050.010.020.050.1由origin作圖,可得到如下:經過線性模擬，我們得到其電導率和濃度之間是線性關系，其相關的數值如下表:從上表中，我們不難發現，電導率和濃度之間的關系的線性關系很強，得到：6.2單釜、不轉、流量Q=4L/h時間(s)電導

9、率(|JS/cm)濃度(mol/L)+c(t)s(mol/L)t2c(t)s2(mol/L)02700.0015207140052700.0015207140.0076035690.038018102700.0015207140.152071153680.0022790680.512790204060.0025731241.029250253970.0025034791.564674303830.0023951432.155628354130.0026272923.218433404410.0028439654.550344454450.0028749185.821709504450.0028

10、749187.187295554670.0030451619.211611604610.00299873110.795431654630.00301420812.735027704800.00314575915.414218754880.00320766518.043117804790.00313802020.083331854680.00305289922.057196904650.00302968424.540442954760.00311480628.1111201004700.00306837630.6837571054690.00306063733.7435271104630.003

11、01420836.4719111154660.00303742240.1699121204590.00298325442.9588621254600.00299099346.7342591304540.00294456349.7631101354640.00302194655.0749631404630.00301420859.0784681454650.00302968463.6991091504740.00309932969.7349011554890.00321540477.2500711604830.00316897481.1257271654720.00308385283.95787

12、91704840.00317671291.8069781754770.00312254495.6279061804630.00301420897.6603241854820.003161235108.1932821904790.003138020113.2825401954700.003068376116.6749862004660.003037422121.4968982054620.003006469126.3468692104550.002952301130.1964762154690.003060637141.4779632204640.003021946146.26217922547

13、20.003083852156.1200242304820.003161235167.2293542354730.003091591170.7330932404620.003006469173.1726272454690.003060637183.7147592504710.003076114192.2571262554670.003045161198.0115792604810.003153497213.1764052654670.003045161213.8464152704630.003014208219.7357292754580.002975516225.0233962804530.

14、002936824230.2470352854600.002990993242.9433742904610.002998731252.1932702954550.002952301256.9239993004580.002975516267.7964383054530.002936824273.1980933104540.002944563282.9724793154560.002960039293.7099053204670.003045161311.8244633254690.003060637323.2798243304560.002960039322.3482863354510.002

15、921348327.8482583404580.002975516343.9696473454500.0029136101.005195278346.7923713504510.002921348357.8651073554530.002936824370.1132993604530.002936824380.6124463654470.002890395385.0728173704400.002836226388.2793943754370.002813011395.5797383804420.002851703411.7859163854480.002898133429.575746390

16、4460.002882656438.4520173954340.002789797435.2780054004350.002797535447.6055764054400.002836226465.2120354104310.002766582465.0623694154370.002813011484.4709004204390.002828488498.9452994254320.002774320501.1115364304360.002805273518.6950074354300.002758843522.0421234404280.002743367531.115789445429

17、0.002751105544.7875664504250.002720152550.8307294554290.002751105569.5475114604280.002743367580.4963894654360.002805273606.5701894704290.002751105607.7190924754260.002727890615.4801954804270.002735628630.2887764854230.002704675636.2072074904220.002696937647.5345304954260.002727890668.4012625004140.0

18、02635030658.7575855104080.002588600673.2949855204130.002627292710.4197655304100.002604077731.4852575404150.002642769770.6313385504020.002542171769.0066135604030.002549909799.6514405703990.002518956818.4087045803970.002503479842.1703595903980.002511217874.1547706003990.002518956906.8240486103950.0024

19、88002925.7857126204000.002526694971.2611746303910.002457049975.2028316403850.002410619987.3896866503900.0024493111034.8338556603870.0024260961056.8074056703810.0023796661068.2321176803770.0023487131086.0448316903760.0023409751114.5379887003760.0023409751147.0775347203710.0023022831193.5035127403680.

20、0022790681248.0176817603640.0022481151298.5111327803640.0022481151367.7530698003570.0021939471404.1258698203570.0021939471475.2097418403520.0021552551520.7480138603480.0021243021571.1336708803490.0021320401651.0519239003450.0021010871701.8804309203440.0020933491771.8102899403400.0020623951822.332575

21、9603380.0020469191886.4403489803350.0020237041943.56517810003320.0020004892.0004889202000.48892010203300.0019850122065.20679710403320.0020004892163.72881610603330.0020082272256.44411610803260.0019540592279.21448811003240.0019385822345.68475211203240.0019385822431.75781311403230.0019308442509.3250311

22、1703210.0019153682621.94658412003190.0018998912735.84288212303180.0018921532862.63763812603160.0018766762979.41075412903110.0018379843058.58985713203110.0018379843202.50403613503070.0018070313293.31430713803070.0018070313441.31016014103040.0017838163546.40506714403020.0017683403666.82903614703010.00

2348337115003000.0017528633943.94175015602980.0017373864228.10349416202960.0017219104518.97997416802920.0016909574772.55568217402900.0016754805072.68294518002890.0016677423.0019348625403.48275218602870.0016522655716.17589019202850.0016367886033.85657319802850.0016367886416.865047由origin作圖得

24、到，時間與濃度之間的關系如下圖:由上表中的數據，用。rigin作圖并模擬積分得：6.3單釜、中轉、流量Q=4L/h時間/s電導率PS/cm濃度(mol/L)tc(t)s(mol/L)t2c(t)s2(mol/L)02840.0016290500053820.0023874040.059685109000.0063958490.639585159820.0070303901.581838209980.0071542032.86168125990.0001974630.0049365670.12341430940.0001587710.0047631340.142894359860.0070613

25、448.650146409810.00702265211.236243459740.00696848414.111180509660.00690657717.266444559560.00682919420.658313609500.00678276524.417952659420.00672085828.395625709330.00665121332.590945759250.00658930737.064850809170.00652740041.775362859090.00646549446.713193909000.00639584951.806377958910.00632620

26、457.0939931008840.00627203662.7203601058750.00620239168.3813641108670.00614048574.2998661158590.00607857880.3891981208510.00601667286.6400741258420.00594702792.9222971308340.00588512199.4585371358270.005830952106.2691071408190.005769046113.0732991458110.005707139119.9926061508050.005660710127.365965

27、1557970.005598803134.5112441607880.005529158141.5464521657810.005474990149.0566061707750.005428560156.8853911757670.005366654164.3537721807610.005320224172.3752551907480.005219626188.4284942007340.005111290204.4515822107210.005010692220.9714962207100.004925570238.3975932306970.004824972255.241023240

28、6870.004747589273.4611252506760.004662468291.4042232606660.004585084309.9517092706550.004499963328.0473062806450.004422580346.7302682906340.004337459364.7802633006260.004275552384.7996853106160.004198169403.4440373206060.004120786421.9684723305970.004051141441.1692633405880.003981496460.260970350580

29、0.003919590480.1497513605720.003857683499.9557583805570.003741609540.2882924005420.003625534580.0854434205280.003517198620.4336714405150.003416600661.4536924605020.003316002701.6659434804910.003230880744.3948005004800.003145759786.4397005204690.003060637827.5963505404590.002983254869.9169515604490.0

30、02905871911.2812055804410.002843965956.7097286004330.0027820581001.5409636304210.0026891991067.3428896604110.0026118151137.7067936904010.0025344321206.6432237203910.0024570491273.7343107503830.0023951431347.2677867803750.0023332361419.5409358103680.0022790681495.2965678403610.0022249001569.889376900

31、3510.0021475171739.4886169603420.0020778721914.96685410203340.0020159662097.41054810803280.0019695362297.26641711403220.0019231062499.26832412003170.0018844142713.55654913203100.0018302463189.02080514403030.0017760783682.87519615602990.0017451254246.93544616802960.0017219104859.91810718002930.001698

32、6955503.77124919202910.0016832186205.01560920402890.0016677426940.47340121602890.0016677427781.01516222802890.0016677428669.58788124002890.0016677424.0025798169606.191558由origin作圖得到，時間與濃度之間的關系如下圖：由上表中的數據，用origin作圖并模擬積分得：0000020c(t)dt=6.094961075；0tc(t)dt=5548.8372942；0tc(t)dt=8186901.1145625otc(t)dt

33、5548.8372942"c”平均停留時間：t二910.40sc(t)dt6.094961075：26.4。tc(t)dt-28186901.1145625-t910.402=514396.3517oc(t)dt6.094961075對于恒容穩態系統有：t二t2t2514396.3517無因次方差：；-22910.402662釜、中轉、流量Q=6L/fl時間/s電導率|JS/cm濃度(mol/L)tc(t)s(mol/L)03070.00180703100518170.3372971017721.3143661517332.8894192016925.0098362516387.56

34、670130160310.65229335156014.09133940152017.90976245147721.99322950143726.37830455140231.09845460137036.1182776513330.00974653741.1791207013000.00949117346.5067487512710.00926676252.1255368012420.00904235157.8710478512020.00873281963.0946159011720.00850066968.8554219511480.00831495075.04242310011240.

35、00812923081.29230410510930.00788934386.98000511010780.00777326894.05654511510470.00753338199.62895812010220.007339923105.6948891259910.007100035110.9380501309790.007007175118.4212661359540.006813718124.1800061409360.006674428130.8187921459150.006511924136.9131951509030.006419064144.4289381558830.006

36、264298150.4997531608710.006171438157.9888131658600.0060863171.004242239165.6999691708550.006047625174.7763641758320.005869644179.7578451808210.005784523187.4185291908020.005637495203.5135562007800.005467252218.6900722107640.005343439235.6456532207460.005204149251.8808242307220.005018430265.474937240

37、7020.004863664280.1470252506920.004786281299.1425332606490.004453533301.0588442706380.004368412318.4572192806230.004252337333.3832312906100.004151739349.1612583005980.004058879365.2991443105840.003950543379.6471863205720.003857683395.0267723305600.003764824409.9892903405490.003679702425.373573350538

38、0.003594581440.3361463605270.003509459454.8259343705160.003424338468.7918673805080.003362431485.5351063905050.003339217507.8948374004950.003261833521.8933524104870.003199927537.9077244204790.003138020553.5468144404620.003006469582.0524414604330.002782058588.6835214804210.002689199619.5913375004110.0

39、02611815652.9538535204010.002534432685.3104975403910.002457049716.4755505603750.002333236731.7028885803660.002263591761.4721676003610.002224900800.9639686203550.002178470837.4038876403490.002132040873.2836626603450.002101087915.2334756803410.002070134957.2298287003370.002039180999.1984307203340.0020

40、159661045.0765367403290.0019772741082.7552377603270.0019617971133.1341617803240.0019385821179.4335568003220.0019231061230.7877258303200.0019076291314.1657568603180.0018921531399.4360488903170.0018844141492.6445439203160.0018766761588.418533由origin作圖得到，時間與濃度之間的關系如下圖:由上表中的數據，用。rigin作圖并模擬積分得:c(t)dt =3.

41、 699037065 ; O tc(t)dt =1130. 84974 0055 :t=c (t) dt =591432.6128125 o、o tc(t) dt 1130.84974 0055平均停留時I可：t二 305.71so c(t)dt 3. 69903706 56. 5單t c(t)dt oc(t)dt59”32&25_57仁66429.659363.699037065266129 65936：.0. 71無因次方差：匚對于恒容穩態系統有:時間/s電導率pS/cm濃度(mol/L)tc(t)s(mol/L),c/>VC/1/T-102850.0016367880053

42、950.0024880020.0622001015001.1038841517002.8319622019475.7991442520009.31749480194792.786301851877100.833385901841110.788550951813121.4848571001786132.5199171051752143.2025031101716153.794751305.7?釜、中轉、流量Q=8L/h1151677164.1026221201647175.3396791251613186.1447501301581197.1492841351546207.67018014015

43、14218.4845581451482229.1629421501453240.1905251601405263.77460617013640.009986425288.60767817513130.009591771293.74798818012810.009344145302.75030218512650.009220332315.56586819012340.008980445324.19404819512140.008825678335.59641920011910.008647697345.90788820511620.008423286353.98860321011420.0082

44、68520364.64173321511220.008113754375.05827022011010.007951249384.84046722510800.007788745394.30520623010600.007633979403.83746823510380.007463736412.18480824010200.007324446421.88810124510000.007169680430.3600422509800.007014914438.4321132559620.006875624447.0874652609450.006744073455.8993312659320.

45、006643475466.5380262709160.006519662475.2833572759000.006395849483.6860812808810.006248821489.9075752858690.006155961500.0179642908520.006024410506.6528912958350.005892859512.8260413008210.005784523520.6070263058080.005683924528.7470753107960.005591065537.3013233157820.005482728544.0237273207680.005374392550