YC橡套電纜技術參數

1、YC 橡套電纜技術參數型號芯數平方mmkg/kmA規格電纜外徑理論重量載流量YC2121.522.511.12165.84202412.82227.29262614.40293.873321019.52575.354721623.00768.096222527.801110.398423532.181488.8010025037.281997.1212527042.242621.5316029546.703328.672002120230YC3131.532.511.91216.21163413.73300.17213615.40397.172831020.95763.383931624.00

2、1023.085332529.791490.067333534.461974.229135030.872702.1811037045.183570.4614039550.134580.42180312054.505603.61210YC31.5+1 13 2.5+1 1.512.92261.531634+12.514.68355.073136+1 416.6476.63383 10+1621.2797.18393 16+1624.961110.2653325+1 1030.671628.4573335+1 1034.092090.3391350+1 1640.893018.41110370+1

3、 2546.133864.72140395+1 3550.584957.481803 120+13553.755869.51310用途： 本產品用于交流額定電壓 Uo/U 450/750V 及以下動 力，家用電器及各種移動或電氣設備和工具用。二、性能： （一）通用橡套軟電纜 ： 1、產品依 據 GB5023-1997 及 JB8735-1998 標準。 2 、電纜長 期允許工作溫度應不超過 65 ； 3、W 型派生電 纜具有耐氣候和一定的耐油性能，適宜于在戶外或接觸油污的場合使用；4、成品電纜應經受下表規定的電壓實驗。實驗條件單位額定電壓 V300/300 300/500450/750試樣長度

4、m整卷整卷溫度室溫室溫實驗電壓v20002500電壓施加時間min55二）電焊機電纜： 1、產品依據 GB5023-1997 標準；2、電纜的長期允許工作溫度應不超過65；3、成品電纜應經受表A 規定的交流 50Hz 浸水電壓實驗；4、成品電纜應經受表B 規定的交流 50Hz 浸水電壓實驗；5、成品電纜應經受表C 規定的靜態曲線實驗表A護套厚度 mm試驗電壓 V 2.060002.0 3.070002.5 3.080003.0 3.510000表B實驗條件單位性能要求試樣長度最小m10浸水時間最小h1水溫20試驗電壓值v2000施加電壓時間最小min5表C標稱截面 mm2最大距離 Lcm標稱截

5、面 mm2最大距離 Lcm1045705516459560254512065355015070505018575三）橡套電纜的型號名稱型號名稱用途YQ，YQW輕型橡套軟電纜用于各種移動電器設 備及工具YZ，YZW中型橡套軟電纜YC，YCW重型橡套軟電纜YH天然膠護套電焊機電纜用于連接電焊機及焊 鉗電纜YHF氯丁膠或其他相當?shù)暮铣赡z彈性 護套電焊機電纜橡套電纜的生產范圍：型號額定電壓芯數標稱截面 mm2YQ YQW300/5002、30.3-0.5YZ YZW450/7502、3、4、50.75-6YC YCW450/75011.5-40021.5-953、41.5-10551.5-25YH Y

6、HW200110-120注：根據用戶需要，還可生產以上規格外的產品 （四）通用橡套軟電纜長期允許載流量?導線工作溫度： 65 環境溫度： 25導線截面 mm2空氣敷設長期允許載流量 AYQ、YQWYZ 、YZWYC 、YCW二芯三芯二芯三芯四芯一芯二芯三芯四芯0.3760.5119121090.75141214121111714131.521181822622222.5302525373026274413536473934346534545525143441075746363161129884842514813511511635183167142143502262081761777028925

7、9224224953533182732731204153713163160.6/126/35kV 塑料絕緣高阻燃（隔氧層）電力電纜Plastic Insulated High PerformanceFlame-retardant Power Cable產品標準 Standard本產品按 GB12706-91額定電壓 35KV 及以下銅芯、 鋁芯塑料絕緣電力電纜 、GB12666.5-90 電線電纜成束燃燒試驗、 GB/T17650-1998 取自電纜或光纜的材料燃燒時釋出氣體的試驗方標準生產 0.6/1kv26/35kv法和 GB/T17651-1998電纜或光纜在特定條件下燃燒的煙密度測定I

8、EC、英國標準、德國標塑料絕緣電力電纜，同時還可根據用戶需要按國際電工委員會推薦標準 準及美國標準生產。The product is manufactured according to the standard of GB12706-91、 GB12666.5-90 、GB/T17650-1998 and GB/T17651-1998 or IEC and DIN and ICEA.適用范圍 Applications本產品適用于工頻額定電壓 0.6/1kv26/35KV 輸配電線路作配送電能之用。The product is suitable for power transmission an

9、d distribution lines with rated voltage 0.6/1kv26/35kv.使用特性 Operating characteristics .工頻額定電壓 U0/U 為 0.6/1kv26/35kv. Rated power frequency voltage U0/U:0.6/1KV26/35KV.PVC絕緣電纜導體的長期最高工作溫度為70。XLPE 絕緣電纜導體的長期允許最高工作溫度為 90PVC insulated power cable Max . permissible continuous operating temperature of the c

10、onductor should not exceed 70 ,XPLE permissible continuous operating temperature of TOC o 1-5 h z the conductor should not exceed 90.短路時（最長持續時間不超過5s ）電纜導體的最高溫度不超過250Max Short circurrt temperature of conductor shall not exceed 250.（5s maximum duration） 電纜敷設時環境溫度不低于0The installation temperature should

11、 not below 0電纜阻燃性能滿足 GB12666.5-90 標準 A 類相應指標要求。The flame-ratardant properties of cable comply with the requirements specified in A kind of GB12666.5-90低鹵電纜除應滿足 GB12666.5-90 標準中 A 類相應指標要求外，還應滿足GB/T17650.1-1998標準規定的相應指標。The flame-retardant properties of lower halogen cable comply with requirements spe

12、cified in A kind of GB12666.5-90 except compluing with requirements specified inGB/T17650.2-1998 .無鹵電纜除應滿足 GB12666.5-90 標準中 A 類相應指標要求外，還應滿足GB/T17650.2-1998和 GB/T17651-1998 標準規定的相應指標。The flame-retardant properties of no halogen cable comply with requirements specified in A kind of GB12666.5-90 except

13、 compluing with requirements specified in GB/T17650.2-1998 .and GB/T17651-1998.電纜彎曲半徑：三芯電纜不小于電纜外徑 15 倍；單芯電纜不小于電纜外徑 20 倍。 Three bending radius of a single core should not less than 20 times of the cable diameter Two bending radius of a three-core cable should not less than 15 times of the cable diame

14、ter.電纜額定電壓的選擇 Voltage designation電纜額定電壓應適合于電纜的系統的運行狀況，用U0/U （ Um）表示，均為有效值，單位為 kvU0- 電纜設計用導體與屏蔽或金屬套之間的額定工作電壓；U電纜設計用導體之間的額定工頻電壓；Um 設備可承受的“最高系統”電壓的最大值。The rated voltage of the cable for a given application shall be suitable for the operating condition in the system in which the cable is used , and is e

15、xpressed in the form ofU0/U ( Um) are applied to the system voltages and running state , and expressed in the form U 0/Ukv.U0-The rated power-frequency voltage between conductor and earth or metallic screen ,for which the cable designed .U-The rated power frequency voltage between conductors for whi

16、ch the cable designed. Um- The maximum value of “ the highest system voltage”for which the equipment maybe used.三相系統用電纜的 U0值推薦如下表： The values U 0 recommended for cables to be used in three-phase systems are listed below:第一類用于單相接地故障時間每一次一般不大于 1min ，亦可用于最長不超過 8 小時， 每年累 計不超過 125 小時的系統。 第二類用于接地故障時間更長的系統

17、及對電纜絕緣性能要求較高 的場合。 The first class cable suitable for one single phase earthing block time does not exceed one minute each time. Max. time not exceed 8 hours ,and not exceed 125 hours in all in one year. The second class cable suitable for more the earthing block time and more better insulated perfor

18、ma.電纜的型號 Type of cable0.6/1kv 高阻燃(隔氧層)電纜的生產范圍 Production Range of high performance flame retardant cable1.8/326/35kv 高阻燃 (隔氧層) 電纜的生產范圍 Production Range of high performance flameretardant cable型號 Type電壓 Rated voltage kv鋁芯 Aluminum芯數1.8/33.6/66/66/108.7/108.7/1512/2018/3026/35銅芯 Copper conductorcoresc

19、onductor標稱截面 Nominal Cross-section Mm 2GZR-YJVGZR-YJLVGZR-DL(WL)-YJVGZR-DL(WL)-YJLV1063025630256303563035630GZR-YJV22GZR-YJLV2211063025630256303563035630GZR-DL(WL)-YJV22GZR-DL(WL)-YJLV221063025630256303563035630GZR-YJV32GZR-YJLV32GZR-DL(WL)-YJV32GZR-DL(WL)-YJLV32GZR-YJVGZR-DL(WL)-YJVGZR-YJLVGZR-DL(W

20、L)-YJLV1050025500255003550035500GZR-YJV 22GZR-YJLV 2231050025500255003550035500GZR-DL(WL)-YJV22GZR-DL(WL)-YJLV221050025500255003550035500GZR-YJV 32GZR-YJLV 32GZR-DL(WL)-YJV32GZR-DL(WL)-YJLV32注：?jiǎn)涡炬z裝型高阻燃（隔氧層）電纜僅用于直流系統，應采用非磁性材料的鎧裝層或采用隔磁措施。 Note: The single-core armoured high performance flame-retardant

21、 cables are used for d.c system only, as for a . c. system non-magnetic aromour materials should be or magnetic isolation should be applied.電纜結構圖20時導體最大直流電阻Max.D.C電纜主要技術參數 Main technical data of cable resistance of conductor at 20 電壓試驗、局部放電試驗 Voltage test and partial discharge導體短路電流 Short circuit cu

22、rrent電容、電感(參考值) Capacitance and inductance of cable (reference value) 電容 Capacitance單芯電纜電感 Inductance of single core cable三芯電纜電感 Inductance of three cores cable電流載流量 The current carrying capacity0.6/1kv 聚氯乙烯絕緣電力電纜 0.6/1kv PVCinsulated power cable (A)在土壤中的敷設 Buried (A)0.6/1KV 交聯聚氯乙烯絕緣非鎧裝型電力電纜 0.6/1kv XPLE insulated unarmoured power cable (A)0.6/1KV 交聯聚乙烯絕緣鎧裝型電力電纜0.6/1kv XLPE insulated armoured power cable (A)