JSJR系列電機技術數據

1、JR、JS系列的電機是中型三相異步電動機，是我國50年代未60年代初統一設計的中型電動機，它分低壓和高壓兩部分， 都是中型三相電動機的基本系列。型系列三相電動機，是我國近年來研制成功的節能新型電機。JR、JS系列的電機基本淘汰被Y系列所取代。 功率相同即是容量相同，只是 丫型系列電機體積比JR、JS系列電機體積小本文摘自：JR系列電動機JR系列電動機為驅動各種不同機械之用，如通風機、壓縮機、水泵、破碎機、切削機床、榆樹機械及其他設備等。本系列電動機一般為為自通風防護式。 電動機應在海拔高度不超過1,000米，使用地點空氣溫度不高于+40 C的室內正常 工作，溫升限度符合國家標準 GB/T755

2、-2000的規定。 本系列電動機符合機械工業部部頒標準 JB563-64和JB564-64 的規定。本系列電動機共分為五個機座號，即11、12、13、14及15號機座。例如：（1） JS147-6表示鼠籠轉子型異步電 動機，14號機座，定子鐵心長度為7號，6極。（2） JR147-10表示繞線轉子型異步電動機，14號機座，定子鐵心長度 為7號，10極、JS JR系列概述J系列中型電機可驅動各種不同的機械，如通風機、壓縮機、水泵、破碎機、球磨機、要削機床、運輸機械及其他設備，可供煤礦、機械工業、發電廠及各種工礦企業中作原動機用。JS系列為鼠籠轉子三相異步電機。JR系列為繞線轉子三相異步電機。JS

3、系列電機符合部頒機準JB563-64技術條件的規定。JR系列電機符合部頒機準JB564-64技術條件的規定。本系列電機為防護式。根據用戶需要也可制成 管道通風式。防護式電機應裝置在海拔高度不超過1KM，周圍空氣溫度不高于+40C，不低于0C,空氣清潔，無酸、堿等腐蝕性 氣體的室內。電機不允許在含有爆炸性氣體或塵埃較多的環境中工作。當電機周圍空氣的溫度超過上述規定或空氣不清潔時，應采用管道通用方式。此時，通入電機兩端的冷卻空氣溫度 應為0C40C并且應保證管道和電機內部的空氣壓力高于周圍空氣的壓力，必要時應加裝鼓風機、濾塵器等。JS系列鼠籠型電機允許全電壓直接起動。最初起動轉矩和最初起動電流數值

4、分別與額定值之比，如表3所示。如用戶的電網不允許全電壓直接起動時，可以采用降低電壓起動。但此時起動轉矩將與起動電壓成平方關系降低JR系列電機在起動時必須預先在轉子回路內接入起動變阻器 。不允許將轉子繞組直接短接起動。二、結構簡述電機的其本安裝型式機座帶底腳臥式安裝，所有型號的電機都可采用聯軸器與被驅動機械聯接。電機采用兩側對稱 的徑向通風系統，冷卻空氣自兩側端蓋的進風口進入，一部分經過電機轉子上的風扇或風葉片吹過定子線圈的端接部分， 另一部分空氣經過轉子鐵心中的徑向通風槽，然后由機座側面的出風口逸出。管道通風式電機的通風系統與上述相同。電機的軸承采用滾動軸承。所用的軸承牌號見表 1,軸承潤滑脂

5、牌號為鋰基潤滑脂ZL-3。表1機座號FrameNO.軸承規格Bearing NO.軸伸端Drivi ng end非軸伸端Non-driv ing end11NU319631912NU320632013NU32263221422228NU3241522230CNU326從電機的軸伸端看，出線盒在機座的右側JS系列電機可以根據用戶的要求制成雙軸伸，其中任一個軸伸均可用以傳達電機的額定功率（球軸承端只能用于聯軸器傳動）。JR系列電機在降低轉矩的條件下，允許長期減速運轉。此進，允許輸出的功率和轉矩與轉速的對應關系應符合表2的規如果電機的負載轉矩（驅動鼓風機、水泵等時）和轉速成平方關系下降時，電機允許在

6、低轉速下長期運轉。表2轉速109680706040Speed(%)0轉矩Torque(%)1009691858062功率Output(%)1009673604825三、型號含義女口： JS115-6表示鼠籠轉子異步電機，11號機座，鐵心長度為5號，6極JR115-6表示繞線型轉子異步電機，11號機座，鐵心長度為5號，6極。JR系列電機分有電刷提升和短路裝置和無電刷提升和短路裝置兩種JS系列(機座號1115 )技術數據型號額定功率(KW)額定電壓(V)滿載時堵轉電流堵轉轉矩最大轉矩轉子飛輪力矩(N m2)被帶動機 構的最大 允許飛輪矩(N m2)冷卻空氣量(m3/s)電機重量(kg)轉速(r/m

7、in)定子電流(A)效率(%)功率因數(cos )額定電流額定轉長額定轉矩JS114-4115147021092.20.8984.751.21.8312025000.5875115-41351475244930.9015.581.452.0814028500.55970116-4155147527893.40.9065.671.52.0516031500.61040117-4180380147532193.80.9066.131.72.1618042000.651100JS126-4225147940093.10.9186.191.332.2833045500.871520127-426014

8、7945793.30.9156.481.432.31360515011630128-43001481527940.9256.91.592.4341059001.151760JS136-4220148025.591.50.9055.21.282.2653053001.32000JS137-4260148030.592.10.95.121.32.2260053001.42110138-4300148034.592.70.9055.511.442.3166045501.52210JS147-43606000148441930.885.31.252.2785036001.23000148-444014

9、845093.50.95.21.262.25100048001.432001410-450014855793.30.925.151.352.35120061501.53550JS158-468014887894.70.895.681.32.41700365024300JS1510-4850148896.595.20.89461.492.47210043502.34800JS1512-41050148811895.50.8965.971.552.37250046502.65200JS115-67598013991.70.8935.091.392.121047000.45895116-695980

10、17592.650.8925.891.72.3924058000.5995117-611598021092.80.8945.911.782.3627084000.531060JS125-6130380984237.5920.9025.941.342.1938069000.671300126-615598428292.30.9036.071.412.1744081000.751380127-618598633193.670.9065.721.672.348093000.81380128-621598638493.950.9046.171.882.24540106000.91450JS136-62

11、4098442393.20.925.851.142.24670136001.11800137-628098649593.50.926.581.312.45770101001.21900JS148-631098836.0492.490.8955.721.532.44145096001.131801410-638098544.0692.90.8936.021.672.531770133501.13450157-64609855393.20.8985.21.32.232300134001.43600158-6550600098562.293.80.875.51.22.12600146001.6390

12、01510-665098573.593.10.886.11.42.33300176001.845001512-678099087.394.60.9085.411.372.154000196002.34800JS115-86073512091.160.8325.151.682.2721086000.38870116-87073513791.60.8425.21.682.21240111000.41950117-88073515592.20.8474.81.542.07270130000.451025JS125-89573518291.50.8654.691.081.83470120000.591

13、250126-811038073421091.70.8664.671.091.803540150000.651400127-813073824293.30.824.881.571.9620189000.71370128-815573929193.40.8665.461.832.12670200000.761440JS136-818073932992.80.8975.661.212.23790186000.881730137-821073838892.80.8835.351.172.08890195000.951830138-8245737443940.8946.341.632.29890234

14、000.951900JS147-8200600074026900.794.91.321250204000.92900148-824074229.9492.40.845.621.732.54145024500131801410-828074234.992.630.8335.911.892.661770196000.853440157-832074238.7930.855.31.532.32300254001.23600158-838074245.693.50.865.41.642.332600272001.339001510-847574356.493.50.834.51.11.93300310

15、001.545001512-857074367.593.70.844.71.2240003590001.74800JS115-10453805879589.70.84.521.582.28240190000.3830116-1055587114900.8084.481.652.24270210000.33920117-1065587134900.814.411.64236990JS125-1080589161910.834.771.23251210126-109558718891.250.844.521.182490268000.613001

16、27-1011558722991.250.834.841.372.08555260000.651430128-1013058725691.650.8384.761.32610251000.651580JS137-1015559029192.30.8755.551.262.381050310000.751820138-1018058833492.50.8835.481.342.141150404000.811980JS1410-1020060005902790.80.795.41.92.72100377000.93300JS157-1026059032.990.740.83174.9921.55

17、82.6113000454001.13600158-103105903991.090.83085.131.6282.6593400508001.239001510-1040059049.691.180.85744.4141.3412.2014200606001.443001512-104805905991.390.85874.2591.3012.0965100726001.646001510-1228049437.490.870.79474.1481.2642.2694200898001.246001512-123304804491.260.79194.2551.3172.3155100103

18、4001.34650型號額定 功率額定電壓(V)滿載時最大轉矩轉子電壓轉子電流轉子飛輪冷卻空電機JR系列(機座號1115)技術數據表.|型號額定 功率 額定 電壓(V)滿載時最大 轉矩 轉子電壓 轉子電流 轉子飛輪冷卻空 電機(KW)轉速(r/min)定子電流(A)效率(%)功率因數(cos)額定轉矩(V)(A)力矩2 (N m )氣量3(m3/S)重量(kg)JR114-41153801450212910.90421734331600.51035115-4135146024692.10.9042.332104081800.551130116-4155146027892.70.9132.282

19、384122000.61200117-4180146032193.10.9112.452754092200.651270JR126-4225147040593.10.9072.22914883700.91660127-42601472461930.922.1833449340011760128-4300147553093.90.9172.373904824401.11890JR136-4220600014752691.70.8941.973074575901.32110137-4260148030.392.30.8971.923464816301.42210138-430014783592.4

20、0.91.963984837101.52320JR147-436014794193.10.9042.685584068501.23000148-444014754993.440.922.6863441010001.433001410-4500148255.594.10.922.4471742012001.53600JR158-46806000148077.893.80.872.772258617001.745001510-4850148395.994.30.9042.580365721001.947001512-41050148011894.40.92.3103563025002.25450J

21、R115-67538096514290.30.891.981273822100.451025116-69597017791.740.8912.331623712400.51115117-611597321392.10.8932.321913812600.551170JR125-613097624591.40.8821.871874454000.671450126-615597729491.10.8731.852194554400.751530127-618597733492.80.9072.273663194900.81560128-621597938593.30.9082.444243175

22、400.91630JR136-6240977436930.9051.854073767601.11970137-628098150793.140.9072.154903608401.22030JR148-6310600098336.891.990.882.250537416501.133601410-638098344.792.50.882.159039118501.13630157-646098554920.87256851723001.43700158-65509856492.50.87261857026001.640001510-665098575930.872.174156033001

23、.845001512-67809858993.50.882.2862570400024750JR115-86038072012089.380.8462.591722302500.38980116-87072313790.270.8562.571992252800.411060117-88072315490.960.8692.452222303100.451135JR125-89572518390.550.8671.892132924500.61380126-811072621290.750.8661.842432945100.651550127-813072824292.150.882.042

24、563245700.71500128-815573229192.540.8752.33093166400.761600JR136-818073534592.250.85823543237700.881850137-8210734400930.861.843943418500.951940138-824573445393.10.861.84253658500.952060JR147-8200600073825.791.60.8182.540629915000.853090148-824073830.6920.8212.4345731916500.8533001410-828074035.792.

25、30.8182.5555030918500.853600JR157-83207393992.50.862.250939523001.23700158-838073845.6930.862.2254743626001.340001510-84757385693.280.8562.03164146833001.545001512-857073866.993.720.861.98169851440001.74750JR115-104538057797880.82.211172522600.3950116-1055577116890.8052.171402562800.331040117-106557

26、7135890.812.161592633100.361110JR125-108057416490.150.8171.961683094600.51350126-109557319390.440.8251.831883265200.51440127-1011538057523390.90.821.922253285800.551590128-1013057526191.140.8261.832513336500.61720JR137-1015558330791.450.85423542809300.751920138-1018058334691.60.861.838730010500.812090JR1410-1020060005902790.50.82.751124821000.93300JR157-1026058833.591.20.812.141240630001.13700158-1031058539.591.70.81244245434001.240001510-1040058550.3920.822.255446742001.445001512-104805856092.90.812.360251251001.64750JR1510-122804903891.40.772.247838042001.245001512-123304904491.