12.康克外墻外保溫施工方案

1、We will continue to improve the company's internal control system, and steady improvement in ability to manage and control, optimize business processes, to ensure smooth processes, responsibilities in place; to further strengthen internal controls, play a control post independent oversight role

2、of evaluation complying with third-party responsibility; to actively make use of internal audit tools detect potential management, streamline, standardize related transactions, strengthening operations in accordance with law. Deepening the information management to ensure full communication "ze

3、ro resistance". To constantly perfect ERP, and BFS+, and PI, and MIS, and SCM, information system based construction, full integration information system, achieved information resources shared; to expand Portal system application of breadth and depth, play information system on enterprise of As

4、sistant role; to perfect daily run maintenance operation of records, promote problem reasons analysis and system handover; to strengthening BFS+, and ERP, and SCM, technology application of training, improve employees application information system of capacity and level. Humanistic care to ensure &q

5、uot;zero." To strengthening Humanities care, continues to foster company wind clear, and gas are, and heart Shun of culture atmosphere; strengthening love helped trapped, care difficult employees; carried out style activities, rich employees life; strengthening health and labour protection, org

6、anization career health medical, control career against; continues to implementation psychological warning prevention system, training employees health of character, and stable of mood and enterprising of attitude, created friendly fraternity of Humanities environment. To strengthen risk management,

7、 ensure that the business of "zero risk". To strengthened business plans management, will business business plans cover to all level, ensure the business can control in control; to close concern financial, and coal electric linkage, and energy-saving scheduling, national policy trends, str

8、engthening track, active should; to implementation State-owned assets method, further specification business financial management; to perfect risk tube control system, achieved risk recognition, and measure, and assessment, and report, and control feedback of closed ring management, improve risk pre

9、vention capacity. To further standardize trading, and strive to achieve "according to law, standardize and fair." Innovation of performance management, to ensure that potential employees "zero fly". To strengthen performance management, process control, enhance employee evaluatio

10、n and levels of effective communication to improve performance management. To further quantify and refine employee standards . Work, full play party, and branch, and members in "five type Enterprise" construction in the of core role, and fighting fortress role and pioneer model role; to co

11、ntinues to strengthening "four good" leadership construction, full play levels cadres in enterprise development in the康克外墻外保溫施工方案(一)(EPS保溫板)一、康克外墻外保溫材料目錄1、康克打底液2、康克粘結劑3、聚苯板4、錨栓5、耐堿玻纖網格布6、康克輕質抹面砂漿二、主要施工工具聚苯板電熱絲切割器、開槽器、萬能刀、剪刀、墨斗、棕刷、粗細紗紙、電動攪拌器、塑料攪拌桶、抹平抹刀、帶齒平抹子、沖擊鉆、錘子、鋼角尺、拖線板、水平靠尺、塑料量杯等。 

12、三、施工條件1、   墻面應清潔、干燥、平整并無松散的砂漿和雜物。門窗框應安裝到位。2、   施工過程中及施工后24小時內，施工現場環境溫度和基層墻體表面溫度不得低于5，風力不大于5級。3、   工時應避免直接日曬和雨淋。必要時，應在腳手架上搭設防曬布遮擋墻面以避免陽光的直射和雨水的沖刷。4、   墻體系統在施工過程中所采取的保護措施，應按設計要求施工完畢后方可拆除。 四、施工工藝流程基面處理-拌制康克粘結劑-粘貼翻包玻纖網格布-粘貼保溫板-安裝固定錨栓-打磨修理-劃分凹線條-拌制康克輕質抹面砂漿-壓入翻

13、包及增強網格布-粘貼網格布-康克輕質抹面砂漿抹平處理-補洞及修理-變形縫處理-修整驗收 （一）基面處理1、   必須徹底清除基層表面的粉塵。松動、不清潔的墻體及模具油、泛白的墻面必須事先清除掉。凹陷部位用康克輕質抹面砂漿進行修平處理?；鶎颖仨毟稍锊⒕哂幸欢ǖ臋C(jī)械強度。2、   對新建工程的結構墻體，用水平靠尺檢查，最大偏差應小2mm/m,超差部分應剔鑿或用水泥砂漿修補平整。3、   康克打底液（1:1用清水稀釋?zhuān)┑氖┕囟葹? -30 ，宜采用滾筒式噴槍的施工方法。對基面進行打底處理。4、 康克打底液施工4小時以上可進行下一

14、步的操作（粘貼聚苯板）。 （二）拌制康克粘結劑1、 康克粘結劑每袋（25公斤）需要約6升干凈水。2、 用量：與基底的平整程度、隔熱保溫板的種類以及粘貼方式有關，大約3-4公斤/平米。具體用量按施工現場實際情況確定。3、 拌制工作應有專人負責，嚴格計量。4、   拌制采用先加水后加粉的機械攪拌方法，嚴格按照粘結劑的需水要求進行攪拌，達到攪拌均勻，無粉塊等，拌好的粘結劑應靜置5分鐘左右再進行攪拌后方可使用。5、   拌制后的粘結劑在使用過程中不可再加水拌制使用。拌好的料應注意防曬避風，以免水份蒸發過快而出現表面結皮現象。6、  

15、 如攪拌桶內的材料放置時間過長，出現表面結皮及部分硬化時，則桶內材料應當作廢料處理。7、   拌制好的康克粘結劑應在30分鐘左右的時間用完（具體時間與現場的環境、濕度有關）。 （三）用康克粘結劑粘貼聚苯保溫板         聚苯板的粘貼可分為條粘法和點粘法。條粘法：采用8mm帶齒平抹子，將康克粘結劑均勻地涂抹在聚苯板上。              

16、;                                條粘法 點粘法：聚苯板周邊涂抹康克粘結劑，寬約20mm,厚約5mm,中間部位均勻布點，點粘面積與苯板面積之比不得小與40%點粘法本系統推薦條粘法，點粘法可作為補充方法使用1、   涂抹粘接的工作平臺，應避免直接放置

17、在風口處，以避免過大的穿堂風而加速粘接劑的表面結皮，進而降低粘接強度。2、   粘結劑以指觸方法確定是否可以使用（指觸不粘粘結劑時不可再使用），攪拌均勻的粘結劑在使用時應在每粘貼一片聚苯板前用抹刀攪拌一下粘結劑以避免結皮。3、   將康克粘結劑涂抹在聚苯板上后，應迅速將聚苯板粘貼在墻上（注意：康克粘結劑涂抹在聚苯板表面后，若在空氣中暴露時間過長，粘結劑表面易形成一層薄薄的結皮而影響粘結強度），然后再用水平尺壓平操作以保證平整度和粘貼牢固。板與板之間要擠緊，板間不留間隙，接縫處不得涂抹康克粘結劑。每帖完一塊應及時清除可能擠出的粘結劑。4、 采用條粘法應注意

18、帶齒抹子的抹刀痕跡應平行、均勻，在聚苯板的表層不應出現平片現象。用帶齒的抹刀涂抹粘結劑時，抹刀底面于聚苯板之間應維持70°-  80° 之間，以保證有足夠的粘結劑用量，同時在聚苯板的四角應補加4個點的粘結劑以增強相應的粘接強度。對有嚴重空鼓現象的聚苯板應取下重貼。（對出現輕微空鼓的聚苯板可用補加錨拴的方法進行加固處理）5、 聚苯板粘結時應無拼接縫，聚苯板之間的縫隙應可能地用切割成相應大小的聚苯板板條來填補，不可用砂漿填充。 6、 如聚苯板之間的表面出現不平整處，可采用砂紙打磨抹平，相應的聚苯板碎屑應及時清除掉。7、 注意留出相應的建筑伸縮縫8、 凡在粘貼

19、的聚苯板側邊外露處（如伸縮縫、建筑沉降縫、溫度縫等縫線兩側，門窗等處），都應做網格布翻包處理。9、 要確保聚苯板粘結劑的用量。10、聚苯板的粘貼應自下而上，并沿水平橫向粘貼以保證連續結合，而且兩排聚苯板豎向錯縫應為1/211、在墻拐角處應先排好尺寸并裁切好聚苯板，使其粘貼時垂直交錯連接，以保證拐角處平整和垂直。12、建議在粘貼聚苯板時，最下層聚苯板離地面的高度為300mm。13、建議在粘貼聚苯板之前，最下層聚苯板可事先錨固相應的聚苯板托架，以提高整個系統的安全性能。仿佛頃刻間，亞運就來到了我們身邊。一個普通的人，很難想象它背后隱藏著多少人的心血，藏匿著多少人的汗水，背負著多少人的夢想，寄托了多

20、少人的祝愿，在這個激動人心的時刻，在這個萬眾矚目的地方of backbone backbone role; to full strengthening members youth work, full play youth employees in company development in the of force role; to improve independent Commission against corruption work level, strengthening on enterprise business key link of effectiveness monit

21、ored. , And maintain stability. To further strengthen publicity and education, improve the overall legal system. We must strengthen safety management, establish and improve the education, supervision, and evaluation as one of the traffic safety management mechanism. To conscientiously sum up the Olympic security controls, promoting integrated management to a higher level, higher standards, a higher level of development. Employees, today is lunar cale