課件卡特彼勒operation and maintenance manual

1、305CR 保養表Operation and Maenance Manual305ini Hydraulic ExcavatorMedia Number -SEBU7428-05Publication Date -01/09/2002Date Updated -16/09/2002i01789649Maenanceerval Schedule在進行機器操作或保養之前,必須閱讀并理解所有的安全信息.警告牌和提示.保養周期表上初始的各項內容都必須完成,機油的更換周期是每 500 小時或 3 個月,如果發下幾種的工況比較惡劣,則每隔 250 小時或一個月更換機油.惡劣工況包括以:高溫,連續的高負荷運

2、轉和工作場所灰塵很大等.參照油樣分析結果來決定是否將機油更換周期從 500 小時降到 250 小時,向你的卡特彼勒SMCS - 7000商請教有關最佳更換機油的周期的詳細信息.All safety information, warnings, and instructions must be read and understoodbefore you perform any operation or any maenance procedure.Before each consecutiveerval is performed, all of the maenancerequirements

3、from the previouserval must also be performed.The normal oil changeerval for the engine is Every 500 Service Hours or 3Months. If the engine is operated under severe conditions, change the oil afterEvery 250 Service Hours or 1 Month. Severe conditions include the following factors: high temperatures

4、, continuous high loads and extremely dusty conditions .Refer to the results of the SOS oilysis in order to determine if the oilchangeerval should be decreased to 250 hours. Consult your CatillarDealer for detailed information regarding the optimum oil changeerval.When Required需要時的保養Every 10 Service

5、 Hours or Dailyfor100 HoursBattery - Recycle蓄電池回收Battery, Battery Cable or Battery Disconnect Switch - Replace蓄電池,蓄電池的電纜或接地開關-更換Bucket Linkage - Inspect/Adjust挖斗連接件檢查,調整 Bucket Tips - Inspect/Replace斗齒檢查/更換Circuit Breakers - Reset斷路器復位最初 100 小時內的每 10 小時或保養Blade Linkage - Lubricate推土鏟連接件潤滑Boom and St

6、ick Linkage - Lubricate大小臂連接件潤滑 Bucket Linkage - Lubricate挖斗連接件潤滑Quick Coupler - Lubricate快速接頭潤滑Cooling System Pre Clean/Replace冷卻系統壓力蓋-re Cap -Every 10 Service Hours or Daily/更換Engine Air Filter Element -Clean/Replace發空氣濾芯清潔/更換Fuel System - Prime燃油系統泵油Fuel System Water Separator -Drain燃油系統的油水分離器排放每

7、 10 小時或保養Cooling System Level - Check冷卻系統液位檢查 Engine Oil Level - Check機油油位檢查Hydraulic System Oil Level - Check系統油位檢查 Indicators and Gauges - Test指示器和儀表測試Travel Alarm - TestFuel DrainWater and Sediment -燃油箱排放水和沉積物Fuses - Replace保險絲更換 Oil Filter - Inspect機油濾芯檢查Radiator Core - Clean散熱器清潔Track Adjustmen

8、t - Inspect調整檢查Track Adjustment - Adjust調整調整Window Washer Reservoir - Fill雨刮器水壺加水Window Wiper - Inspect/Replace雨刮器檢查/更換行走-測試Undercarriage - Check底盤檢查Walk-Around Inspection繞機一圈檢查 Windows - Clean窗戶玻璃清潔Every 10 Service Hours or Dailyfor Machines Used in SevereApplications在機器使用工況較惡劣時的每機器工況比較惡劣時的每 100 小時

9、或 2 周的保養10 小時或保養Blade Linkage - Lubricate推土鏟連接件潤滑 Bucket Linkage - Lubricate挖斗連接件潤滑Quick Coupler - Lubricate快速接頭潤滑Boom and Stick Linkage - Lubricate大小臂連接件潤滑Initial 250 Service Hours最初 250 小時保養Every 50 Service HoursEngine Valve Lash - Check氣門間隙檢查 Final Drive Oil - Change終傳動油更換Hydraulic System Oil Fil

10、ter (Return)- Replace油濾芯(回油)更換每 50 小時保養Bucket Linkage - Lubricate挖斗連接件潤滑 Quick Coupler - Lubricate快速接頭潤滑Every 250 Service HoursInitial 100 Service Hours每 250 小時保養最初 100 小時保養Battery Electrolyevel (LowMaenance) - Check/AddEngine Oil and Filter - Change機油和機濾更換蓄電池電解液液位檢查/添加Cooling System Hoses - Inspect

11、冷卻系統軟管檢查Engine Oil and Filter - ChangeEvery 100 Service Hours機油和濾芯更換發每 100 小時保養Betn 250 Service Hours andSwing Bearing - Lubricate回轉軸承潤滑 Swing Gear - Lubricate回轉齒輪潤滑1000 Service Hours在 250 小時到 1000 小時之間Every 100 Service Hours or 2ks for Machines Used inSevere ApplicationsBelt - Inspect/Adjust/Replac

12、e皮帶檢查/調整/更換Every 250 Service Hours orMonthly每 250 小時或一個月保養Every 3000 Service Hours or 3YearsCondenser (Refrigerant) - Clean冷凝器(制冷劑)清潔每 3000 小時保養Every 500 Service HoursCooling System Coolant (ELC) -Change冷卻系統的冷卻液(ELC)更換每 500 小時保養Blade Linkage - Lubricate推土鏟連接件潤滑Boom and Stick Linkage - Lubricate大小臂連接件潤滑 Fuel System Filter - Replace燃油系統的濾芯更換FuelCap and Strainer - Clean燃油箱蓋和濾網清潔Hydraulic System Oil Filter (Return)- Replace系統的濾芯(回油)更換Every 1000 Service Hours每 1000 小時保養Battery - Clean蓄電池清潔B