過濾器,反滲透,混床步序表

1、PT. PLN BATAM Tanjung Kasam Coal Fired Steam Power Plant 2x65MW Power Plant Project印尼BATAM TJK 2 X 65MW燃煤電廠工程DESALINATION WATER TREATMENT SYSTEM 海水淡化及鍋爐補給水處理系統 步序表OPERATION PROCEDURE TABLE中國華電工程（集團）有限公司CHINA HUADIAN ENGINEERING CO., LTD.1. 多介質過濾器(Multi-media Filter )序號閥門/設備名稱VALVE/EQUIPMENT NAMEKKS編

2、碼KKS Code運行Put into run停用反洗Backflush ing充水Filli ng正洗Ri nsing運行Service停用OFF排水1Drain空氣擦洗SCOURING水反洗Water BACKFLUSHING1.進水閥INLETAOGCB51AA102開開開關關關關2.出水閥OUTLETAOGCB51AA106關關開關關關關3.反洗進水閥BACKFLUSHING INLETAOGCB51AA103關關關關關關開4.反洗排水閥BACKFLUSHING DRAINAOGCB51AA105關關關關關關開5.正洗排水閥RINSING DRAINAOGCB51AA107關開關關開關

3、關6.擦洗空氣進口閥AOGCB51關關關關關開關SCOURING AIR INLETAA1047.排氣閥VENTAOGCB51AA101開關關關開開關8.流量FLOW7om/h7om/h7om/h4NnVmi n4Nrn/mi n9.持續時間TIME2min15mi n現場設定5 10mi n5 10mi n備注：1. 排水至濾料層上200mm該步序結束。2. 過濾器投入運行，同時加入凝聚劑，凝聚劑投加量根據進出水濁度和流量調節。2. 海水反滲透單元（SWRO Uni）序號閥門/設備名 稱VALVE/EQUIPMENTNAMEKKS編碼KKS Code運行Put into run停用OFF打開

4、產水排放閥Open PermeateDischargeValve沖洗Sluici ng產水排放1PermeateDischarge運行Service打開產水排放閥Ope nPermeateDischargeValve停泵Pump Stop低壓沖洗Sluici ng停止OFF1.反滲透進水閥RO In letAOGCF41AA101關開開開開關關關2.產水排放閥AOGCF41PermeateAA102開開開關開開開關Discharge3.低壓沖洗進水閥AOGCF41AA103關關關關關關關關Sluice In let4.一級咼壓泵AOGCF41SWRO HighAP001關關開開開關關關Pres

5、sure Pump5.增壓泵Booster PumpAOGCF41AP002關關開開開關關關6.海水反滲透沖AOGCP31洗水泵SWRCFlush ingPumpsAP001關關關關關關開關7.酸計量泵AOGCN81Acid Dosi ngAP001關關開開開關關關Pump8.還原劑計量泵A0QCB21AP001/SBS Dosi ngA0QCB22AP001關開開開開關關關Pump9.阻垢劑計量泵A0QCF21AP001/關關開開開關關關ScaleIn hibitorDosing PumpA0QCF22AP00110.流量FLOW高壓泵10mi n高壓泵流流量：.,3量：25m/h325m/

6、h增壓泵流增壓3量：46m/h泵流量：346m/h11.持續時間TIME15mi n5min10mi n備注：1. 初濾水排放至產品水電導到設定值，該步序結束。2. SWRO起動前先過濾器（1套反滲透，至少起動 2臺過濾器）；海水反滲透停止運行后，過濾器才能退出運行。3. 還原劑計量泵和 ORP連鎖；酸計量泵和 pH連鎖4. 高壓泵和進口壓力開關連鎖。5. 高壓泵和增壓泵連鎖，保持流量和壓力穩定。3. 二級反滲透單元（BWRO Uni）序號閥門/設備名 稱VALVE/EQUIPMENTNAMEKKS編碼KKS Code運行Put into run停用OFF打開產水排放閥Open Permeat

7、eDischargeValve沖洗Sluici ng產水排放1PermeateDischarge運行Service打開產水排放閥Open PermeateDischargeValve停咼壓泵HighPressurePump Stop低壓沖洗Sluici ng停止OFF1.產水排放閥AOGCF43PermeateAA102開開開關開開開關Discharge2.低壓沖洗進水AOGCF43閥AA103關關關關關關關關Sluice In let3.二級咼壓泵BWRO HighAOGCF43AP001關關開開開關關關PressurePump4.反滲透沖洗水泵BWROFlush ingPumpsAOGCP

8、32AP001關關關關關關開關5.堿計量泵CausticDosing PumpAOGCN85AP001關關開開開關關關6.流量FLOW15mi n5min10mi n7.持續時間TIME備注：1. 初濾水排放至產品水電導到設定值，該步序結束。2. 堿計量泵和pH連鎖。3. 高壓泵和進口壓力開關連鎖。4.混床(Mixed Bed Polisher )設備名稱閥門名稱VALVE NAMEKKS碼KKSCODE運行步驟運行service停用off反洗分層Backflush ingfor separati on沉降Settle再生Rege nerati on置換displaceme nt排水drain

9、混脂Resi nmixi ng設備充水filli ng正洗rin si ng停用off混床Mixed bedpolisher進水閥NLET VALVEA0GCF21AA102開所有表中所列閥門、泵處于關閉狀態關關關關關關開開所有表所列閥 泵處于 閉狀態出水閥OUTLET VALVEA0GCF21AA110開關關關關關關關關反洗進水閥3ACKFULISHINGNLETA0GCF21AA104關開關關關關關關關反洗排水閥BACKFLUSHINGDRAINA0GCF21AA107關開關關關關開關關中排閥MIDDLEDRAINVALVEA0GCF21AA108關關關開開關關關關進酸閥ACID INLE

10、TA0GCF21AA105關關關開開關關關關進堿閥CAUSTIC INLETA0GCF21AA103關關關開開關關關關非積水閥op DrainA0GCF21AA109關關關關關開關關關進壓縮空氣AIR INLETA0GCF21AA106關關關關關關開關關正洗排水閥RINSINGA0GCF21AA111關關關關關關關關開非氣閥VENTA0GCF21AA101關關開關關開關開關混床用酸噴射器進稀釋水閥AcidDilutionwater inletA0GCN8：AA1013關關關開開關關關關進酸閥Acid in letA0GCN8：AA1023關關關開關關關關關混床用堿噴射器進稀釋水閥Caustic dilutio nwater inletA0GCN8AA1017關關關開開關關關關進堿閥Caustic inletA