汽車專業英語課件(宋進桂)

1、Chapter 6 Automotive Electrical and Electronic Systems 6.1 Lead Acid Battery and Circuit protection devices 6.2 Charging System 6.3 Starting System 6.4 Ignition Systems 6.5 Lighting System 6.6 power window system6.7 Supplemental Restraint Systems 6.8 Cruise control systems 6.9 Anti Theft Systems 6.1

2、0 Air Conditioning Chapter 6 Automotive Electrical and Electronic Systems 6.1 Lead Acid Battery and Circuit protection devices New Wordselectrochemicalilektrukemikl a.電化（學）的電化（學）的overloaduvludn.超載，過載，過負荷超載，過載，過負荷fusiblefju:zbla.易熔的，可熔化的易熔的，可熔化的relayrilein.繼電器繼電器bimetallicbaimitlika.雙金屬的雙金屬的stripstri

3、pn.條，帶條，帶remainderrimeindn.剩余物，其余的人；剩余物，其余的人；a.剩余的剩余的exceediksi:dv.超過，勝過超過，勝過Chapter 6 Automotive Electrical and Electronic Systems 6.1 Lead Acid Battery and Circuit protection devices 6.1.1 lead-acid storage batteryA lead-acid storage battery (Figure 6-1) is an electrochemical device that produces

4、voltage and delivers electrical current. The battery is the primary source of electrical energy used in vehicles today. When charging, the battery converts electricity into chemical energy, and when discharging, it converts chemical energy into electricity, producing a current.6.1.2 Circuit protecti

5、on devicesIt is necessary to protect electrical circuit against shorting (accidentally touching ground) that could burn up the wiring. Electrical units must be protected against overloads also. In circuits, Circuit protection devices must be installed in series with the electrical devices or wiring

6、to be protected. The common types of circuit protection devices are fuse, fusible link and circuit breaker, see Table 6-1.Chapter 6 Automotive Electrical and Electronic Systems 6.1 Lead Acid Battery and Circuit protection devices All of the vehicle fuses are usually contained in a holder called fuse

7、 block or relay block (Figure 6-2 and 6-3).A circuit may be protected by a special wire that acts as a fuse. This wire is called a fusible link. A Circuit breaker feeds current through a bimetallic strip and a set of points to the remainder of the circuit. When the current exceeds the breakers ratin

8、g, the bimetallic strip heats and bends to separate the points. Once it cools, it will close the circuit. Relays are used to direct large current flows that might overheat and damage a switch, they are a type of solenoid switch that closes electrical contacts. Most of relays are usually contained in

9、 relay block and junction block (J/B). Figure 6-1 Battery constructionChapter 6 Automotive Electrical and Electronic Systems 6.1 Lead Acid Battery and Circuit protection devices Table 6-1 Circuit protection devices used for Toyota automotive wiring diaghramsIllustration Symbol Name AbbraviationFuseF

10、useMedium current fuseM-FuseHigh current fuseH-FuseFusible linkFLCircuit breakerCBChapter 6 Automotive Electrical and Electronic Systems 6.1 Lead Acid Battery and Circuit protection devices Figure 6-2 Location of use block, relay block and junction block in a passenger carChapter 6 Automotive Electr

11、ical and Electronic Systems 6.1 Lead Acid Battery and Circuit protection devices Figure 6-3 Location of use block, relay block and junction block in a vanChapter 6 Automotive Electrical and Electronic Systems 6.2 Charging System rotationruteinn.旋轉旋轉alternator:ltneitn.（交流）發電機（交流）發電機regulatorregjuleit

12、n.調節器，調節閥調節器，調節閥rectifierrektifain.整流器整流器explodeikspludv.爆炸，爆破爆炸，爆破New WordsThe charging system uses the rotation of the engine to create electricity. The electricity recharges the battery and provides power to operate the various vehicle electrical systems. The modern vehicle charging system consis

13、ts of alternator and voltage regulator (Figure 6-4 and 6-5).Chapter 6 Automotive Electrical and Electronic Systems 6.2 Charging System Figure 6-4 Components of a typical AC generatorFigure 6-4 Components of a typical AC generatorChapter 6 Automotive Electrical and Electronic Systems 6.2 Charging Sys

14、tem Figure 6-5 Exploded view of a typical alternator (with voltage regulator)Figure 6-5 Exploded view of a typical alternator (with voltage regulator)Chapter 6 Automotive Electrical and Electronic Systems 6.3 Starting System armature:mtju n.轉子，電樞轉子，電樞energizeendaiz v.供給供給.能量，激勵，勵磁，通電能量，激勵，勵磁，通電chrom

15、ekrumn.鉻鉻 Modern internal combustion engines are started by using electric starting motor, or starter (Figure 6-6, 6-7 and 6-8). A starting system consists of battery, ignition switch, starter relay and starter. To energize the starter, the ignition switch is turned to START, which completes an elec

16、trical circuit. When the starter begins to turn the starter gear moves out and engages the ring gear, which spins the crankshaft. New WordsChapter 6 Automotive Electrical and Electronic Systems 6.3 Starting System Figure 6-6 Starting motor components Figure 6-6 Starting motor components Chapter 6 Automotive Elec