25m簡支小箱梁計算書

五、模型建立與分析本橋整體模型采用空間有限元程序MIDASCIVIL2012計算，并以《公路橋涵設計通用規范》（JTGD60-2004）和《公路鋼筋混凝土及預應力混凝土橋涵設計規范》（JTGD62-2004）為標準，按A類預應力混凝土結構進行驗算。主橋采用梁格法建立模型進行分析。采用梁單元建模時，對于簡支小箱梁、端橫梁以及中橫梁采用梁單元進行模擬，其截面特性按照實際設計截面定義。采用虛擬橫梁模擬小箱梁之間的橫向聯系，其截面特性取頂板厚度及虛擬橫梁之間的寬度進行定義，不考慮虛擬橫梁的自重。梁單元整體模型如下圖所示：5.SEQ圖表\*ARABIC1計算模型圖在Midas模型中按照實際的施工順序模擬施工。在施工過程中，結構的安裝與拆除、荷載的加載與卸載、邊界條件的改變等均通過相應組的激活與鈍化實現。六、持久狀況承載能力極限狀態驗算結果6.1截面受壓區高度表SEQ表格\*ARABIC6.1截面受壓區高度相對界限受壓區高度ξb鋼筋種類C50及以下C55/C60C65/C70C75/C80R2350.620.600.58-HRB3350.560.540.52-HRB400/KL4000.530.510.49-鋼絞線、鋼絲0.400.380.360.35精軋螺紋鋼筋0.400.380.36-6.2正截面抗彎承載能力驗算圖6.1正截面抗彎承載能力驗算結果圖形結論：按照《公路鋼筋混凝土及預應力混凝土橋涵設計規范》（JTGD62-2004）第5.1.5條EQγos≤R驗算，結構重要性系數x作用效應的組合設計最大值均小于等于構件承載力設計值，滿足規范要求。6.3支反力計算表6.2支反力計算結果表格節點FX(kN)FY(kN)FZ(kN)MX(kN·m)MY(kN·m)MZ(kN·m)226-11.0105.9651041.9430.0000.0000.00022711.1056.001986.2540.0000.0000.000228-11.1074.7361214.8240.0000.0000.00022911.2334.5421249.5980.0000.0000.000230-11.1583.2751431.0510.0000.0000.00023111.2403.0301445.7450.0000.0000.000232-11.1821.7441558.9910.0000.0000.00023311.2211.4821559.9950.0000.0000.000234-11.202-0.3341347.5020.0000.0000.00023511.199-0.4261324.4700.0000.0000.000236-11.223-1.4821042.4180.0000.0000.00023711.180-1.7441007.0970.0000.0000.000238-11.220-3.035949.3000.0000.0000.00023911.156-3.274933.8020.0000.0000.000240-11.236-4.543999.0300.0000.0000.00024111.105-4.734985.6630.0000.0000.000242-11.108-6.0021065.0770.0000.0000.00024311.006-5.9621125.9140.0000.0000.000七、持久狀況正常使用極限狀態驗算結果7.1結構正截面抗裂驗算對于部分預應力A類構件，在作用（荷載）短期效應組合下，應符合下列條件：EQσst－σpc≤0.7ftk但在荷載長期效應組合下：EQσlt－σpc≤0圖7.1結構正截面抗裂驗算短期效應組合結果圖形圖7.2結構正截面抗裂驗算長期效應組合結果圖形結論：按照《公路鋼筋混凝土及預應力混凝土橋涵設計規范》（JTGD62-2004）第6.3.1-1條驗算:短期效應組合EQσst－σpc=1.94MPa≤0.7ftk=0.00MPa，滿足規范要求。長期效應組合EQσst－σpc=1.94MPa≤0.7ftk=0.00MPa，滿足規范要求。7.2結構斜截面抗裂驗算對于A類和B類部分預應力混凝土構件，在作用（荷載）短期效應組合下，應符合下列條件：預制構件：EQσtp≤0.7ftk現場澆筑（包括預制拼裝）構件：EQσtp≤0.5ftk圖7.3結構斜截面抗裂驗算結果圖形結論：按照《公路鋼筋混凝土及預應力混凝土橋涵設計規范》（JTGD62-2004）第6.3.1-2條驗算:EQσtp=-0.26MPa≤0.7ftk=-1.86MPa，滿足規范要求。八、持久狀況構件應力驗算結果8.1正截面混凝土法向壓應力驗算按《公路鋼筋混凝土及預應力混凝土橋涵設計規范》（JTGD62-2004）第7.1.5-1條，荷載取其標準值，汽車荷載考慮沖擊系數。受壓區混凝土的最大壓應力：未開裂構件：EQσkc＋σpt≤0.5fck允許開裂構件：EQσcc≤0.5fck圖8.1正截面混凝土法向壓應力驗算結果圖形結論：按照《公路鋼筋混凝土及預應力混凝土橋涵設計規范》（JTGD62-2004）第7.1.5條驗算:EQσkc＋σpt=10.80MPa≤0.5fck=16.20MPa，滿足規范要求。8.2斜截面混凝土的主壓應力驗算按《公路鋼筋混凝土及預應力混凝土橋涵設計規范》（JTGD62-2004）第7.1.6條，混凝土的主壓應力應符合下式規定：EQσcp≤0.6fck圖8.2斜截面混凝土的主壓應力驗算結果圖形結論：按照《公路鋼筋混凝土及預應力混凝土橋涵設計規范》（JTGD62-2004）第7.1.6條驗算：EQσcp=10.80MPa≤0.6fck=19.44MPa，滿足規范要求。九、詳細計算表格說明：表格中軸力和剪力單位kN，彎矩和扭矩單位kN·m，應力單位MPa。表9.1正截面抗彎承載能力驗算詳細計算表格單元位置最大/最小組合名稱類型驗算rMuMn2I最大cLCB15MY-MAXOK76.184799.932I最小cLCB34MY-MINOK-6.282694.642J最大cLCB15MY-MAXOK1651.876170.482J最小cLCB34MY-MINOK1253.716170.483I最大cLCB15MY-MAXOK1651.876170.483I最小cLCB34MY-MINOK1253.726170.483J最大cLCB15MY-MAXOK2474.976587.213J最小cLCB34MY-MINOK1865.156587.214I最大cLCB15MY-MAXOK2534.166587.214I最小cLCB34MY-MINOK1863.246587.214J最大cLCB16MY-MAXOK5747.778130.694J最小cLCB33MY-MINOK4178.198130.695I最大cLCB16MY-MAXOK5826.268130.695I最小cLCB23-OK4182.588130.695J最大cLCB16MY-MAXOK7041.188233.815J最小cLCB23-OK4998.948233.816I最大cLCB16MY-MAXOK7068.118233.816I最小cLCB23-OK4993.148233.816J最大cLCB16MY-MAXOK6073.128133.266J最小cLCB23-OK4283.858133.267I最大cLCB16MY-MAXOK6023.608133.267I最小cLCB23-OK4275.488133.267J最大cLCB16MY-MAXOK2755.116597.647J最小cLCB33MY-MINOK1927.036597.648I最大cLCB16MY-MAXOK2658.816597.648I最小cLCB29MY-MINOK1935.526597.648J最大cLCB15MY-MAXOK1805.706182.068J最小cLCB30MY-MINOK1306.776182.069I最大cLCB15MY-MAXOK1805.706182.069I最小cLCB30MY-MINOK1306.776182.069J最大cLCB15MY-MAXOK95.614799.319J最小cLCB34MY-MINOK19.454799.3126I最大cLCB15MY-MAXOK99.784764.8826I最小cLCB34MY-MINOK-58.902694.3026J最大cLCB15MY-MAXOK1812.706134.8626J最小cLCB34MY-MINOK1219.556134.8627I最大cLCB15MY-MAXOK1812.706134.8627I最小cLCB34MY-MINOK1219.556134.8627J最大cLCB15MY-MAXOK2745.496551.5927J最小cLCB34MY-MINOK1810.436551.5928I最大cLCB15MY-MAXOK2766.656551.5928I最小cLCB24-OK1770.886551.5928J最大cLCB15MY-MAXOK6167.308095.0728J最小cLCB24-OK4072.528095.0729I最大cLCB15MY-MAXOK6212.948095.0729I最小cLCB24-OK4045.498095.0729J最大cLCB15MY-MAXOK7312.318198.1929J最小cLCB24-OK4821.668198.1930I最大cLCB15MY-MAXOK7400.248198.1930I最小cLCB24-OK4829.148198.1930J最大cLCB15MY-MAXOK6244.328097.6430J最小cLCB24-OK4077.438097.6431I最大cLCB15MY-MAXOK6351.208097.6431I最小cLCB24-OK4113.408097.6431J最大cLCB15MY-MAXOK2865.566562.0231J最小cLCB24-OK1811.796562.0232I最大cLCB15MY-MAXOK2908.346562.0232I最小cLCB34MY-MINOK1835.076562.0232J最大cLCB15MY-MAXOK1976.716146.4432J最小cLCB34MY-MINOK1237.886146.4433I最大cLCB15MY-MAXOK1976.716146.4433I最小cLCB34MY-MINOK1237.886146.4433J最大cLCB11MY-MAXOK147.944764.4133J最小cLCB34MY-MINOK18.644764.41表9.2結構正截面抗裂驗算詳細計算表格單元位置組合名稱短/長類型驗算Sig_TSig_BSig_MAXSig_ALW2IcLCB54短期MY-MINOK0.899.110.85-1.862JcLCB54短期MX-MAXOK1.949.441.34-1.862IcLCB62長期MY-MINOK1.849.341.790.002JcLCB62長期MX-MAXOK2.879.692.310.003IcLCB54短期FX-MINOK1.989.391.35-1.863JcLCB54短期FX-MINOK2.428.661.40-1.863IcLCB62長期FX-MINOK2.889.652.300.003JcLCB62長期FX-MINOK3.318.932.370.004IcLCB50短期MZ-MAXOK2.488.572.12-1.864JcLCB50短期FY-MINOK3.956.253.83-1.864IcLCB61長期MZ-MAXOK3.328.883.080.004JcLCB61長期FY-MINOK4.846.504.720.005IcLCB54短期FX-MAXOK4.016.253.89-1.865JcLCB56短期MY-MAXOK6.163.173.15-1.865IcLCB62長期FX-MAXOK4.906.494.800.005JcLCB62長期MY-MAXOK6.683.943.920.006IcLCB56短期MY-MAXOK6.183.153.15-1.866JcLCB54短期FX-MAXOK4.215.964.07-1.866IcLCB62長期MY-MAXOK6.693.933.930.006JcLCB62長期FX-MAXOK5.106.214.960.007IcLCB58短期FX-MINOK4.145.964.09-1.867JcLCB54短期MY-MINOK2.458.562.13-1.867IcLCB63長期FX-MINOK5.036.214.980.007JcLCB62長期MY-MINOK3.348.803.050.008IcLCB54短期MX-MINOK2.408.531.39-1.868JcLCB54短期MX-MINOK1.949.281.32-1.868IcLCB62長期MX-MINOK3.308.792.290.008JcLCB62長期MX-MINOK2.859.532.230.009IcLCB54短期MX-MINOK1.939.291.31-1.869JcLCB54短期MX-MINOK0.849.000.78-1.869IcLCB62長期MX-MINOK2.869.552.240.009JcLCB62長期MX-MINOK1.789.261.720.0026IcLCB54短期MY-MINOK1.159.071.07-1.8626JcLCB54短期MX-MAXOK2.289.401.97-1.8626IcLCB62長期MY-MINOK2.059.291.960.0026JcLCB62長期MX-MAXOK3.149.662.860.0027IcLCB54短期MX-MAXOK2.299.391.98-1.8627JcLCB54短期MX-MAXOK2.718.742.16-1.8627IcLCB62長期MX-MAXOK3.129.642.850.0027JcLCB62長期MX-MAXOK3.548.993.050.0028IcLCB54短期MX-MAXOK2.558.772.34-1.8628JcLCB50短期MY-MINOK4.236.344.21-1.8628IcLCB62長期MX-MAXOK3.419.013.230.0028JcLCB61長期MY-MINOK5.096.575.080.0029IcLCB54短期MY-MINOK4.136.404.02-1.8629JcLCB56短期MY-MAXOK6.662.792.74-1.8629IcLCB62長期MY-MINOK5.016.624.910.0029JcLCB62長期MY-MAXOK7.013.813.780.0030IcLCB56短期MY-MAXOK6.742.672.64-1.8630JcLCB54短期MY-MINOK4.206.334.08-1.8630IcLCB62長期MY-MAXOK7.063.743.720.0030JcLCB62長期MY-MINOK5.076.554.970.0031IcLCB58短期FY-MAXOK4.326.254.30-1.8631JcLCB54短期MY-MINOK2.608.742.46-1.8631IcLCB63長期FY-MAXOK5.186.495.160.0031JcLCB62長期MY-MINOK3.468.973.360.0032IcLCB54短期MX-MINOK2.698.682.16-1.8632JcLCB54短期MY-MINOK2.269.351.97-1.8632IcLCB62長期MX-MINOK3.528.933.080.0032JcLCB62長期MY-MINOK3.109.602.860.0033IcLCB54短期MY-MINOK2.259.361.95-1.8633JcLCB54短期MY-MINOK1.178.911.07-1.8633IcLCB62長期MY-MINOK3.119.622.860.0033JcLCB62長期MY-MINOK2.049.181.940.00表9.3結構斜截面抗裂驗算詳細計算表格單元位置組合名稱最大/最小Sig_P2Sig_P3Sig_P7Sig_P10Sig_MAXSig_AP2IcLCB87OK4.0810.063.7210.0110.1019.442JcLCB87OK5.6510.604.0110.5510.6019.443IcLCB87OK5.6010.544.0110.5410.5419.443JcLCB87OK6.469.993.769.989.9919.444IcLCB87OK5.509.644.169.639.6419.444JcLCB89OK8.205.734.225.738.2019.445IcLCB89OK8.475.694.225.698.4719.445JcLCB89OK9.933.314.283.319.9319.446IcLCB89OK9.883.224.333.229.8819.446JcLCB89OK8.845.224.195.228.8419.447IcLCB89OK8.335.104.335.108.5419.447JcLCB87OK5.809.593.999.589.5919.448IcLCB87OK6.669.953.549.959.9519.448JcLCB87OK5.7910.503.8110.5010.5019.449IcLCB87OK5.8610.563.8210.6010.6019.449JcLCB87OK4.049.933.639.9610.0119.4426IcLCB87OK4.0110.113.9110.0610.1919.4426JcLCB87OK5.7110.534.2310.4810.5319.4427IcLCB87OK5.6510.484.2110.4710.4819.4427JcLCB87OK6.369.943.999.949.9419.4428IcLCB87OK5.629.724.309.719.7219.4428JcLCB89OK9.164.734.324.739.1619.4429IcLCB89OK9.224.594.204.599.2219.4429JcLCB89OK10.702.464.282.4610.7019.4430IcLCB89OK10.802.264.292.2710.8019.4430JcLCB89OK9.274.544.234.549.2719.4431IcLCB89OK9.424.354.304.359.4219.4431JcLCB87OK5.689.664.299.659.6619.4432IcLCB87OK6.189.893.959.899.8919.4432JcLCB87OK5.5010.454.1410.4410.4519.4433IcLCB87OK5.5810.514.1810.5510.5519.4433JcLCB87OK4.059.893.819.9310.0119.44表9.4正截面混凝土法向壓應力驗算詳細計算表格單元位置組合名稱類型驗算Sig_TSig_BSig_MAXSig_ALW2IcLCB87MX-MINOK4.1410.0810.1016.202JcLCB87MY-MINOK5.1910.3910.6016.203IcLCB87MY-MINOK5.1210.3310.5416.203JcLCB87MX-MAXOK5.579.609.9916.204IcLCB87MY-MINOK5.489.639.6416.204JcLCB89MY-MAXOK8.095.688.2016.205IcLCB89MZ-MAXOK8.255.598.4716.205JcLCB89MY-MAXOK9.843.269.9316.206IcLCB89MY-MAXOK9.873.219.8816.206JcLCB89MY-MAXOK8.585.118.8416.207IcLCB89MY-MAXOK8.435.148.5416.207JcLCB87MY-MINOK5.549.489.5916.208IcLCB87MX-MINOK5.559.469.9516.208JcLCB87MX-MINOK5.1010.2010.5016.209IcLCB87MX-MINOK5.1710.2610.5616.209JcLCB87MY-MINOK4.099.959.9716.2026IcLCB87MX-MINOK4.1110.1510.1916.2026JcLCB87MX-MAXOK5.3010.3610.5316.2027IcLCB87MX-MAXOK5.2310.3010.4816.2027JcLCB87MX-MAXOK5.659.659.9416.2028IcLCB87MY-MINOK5.539.689.7216.2028JcLCB89MY-MAXOK8.964.659.1616.2029IcLCB89MY-MAXOK8.994.509.2216.2029JcLCB89MY-MAXOK10.542.3910.7016.2030IcLCB89MY-MAXOK10.662.2010.8016.2030JcLCB89MY-MAXOK9.064.459.2716.2031IcLCB89MY-MAXOK9.224.259.4216.2031JcLCB87MY-MINOK5.609.639.6616.2032IcLCB87MY-MINOK5.589.649.8916.2032JcLCB87MY-MINOK5.1610.3010.4516.2033IcLCB87MY-MINOK5.2310.3710.5116.2033JcLCB87MX-MINOK4.159.939.9716.20表9.5斜截面混凝土的主壓應力驗算詳細計算表格單元位置組合名稱最大/最小Sig_P2Sig_P3Sig_P7Sig_P10Sig_MAXSig_AP2IcLCB87OK4.0810.063.7210.0110.1019.442JcLCB87OK5.6510.604.0110.5510.6019.443IcLCB87OK5.6010.544.0110.5410.5419.443J