公路橋梁板式橡膠支座尺寸表

板式橡膠支座一、公路橋梁板式橡膠支座規格系列1、范圍本標準規定了板式橡膠支座的要求、規格系列及選用。本標準適用于承載力小于5000kN的公路橋梁用矩形、圓形平板式橡膠支座。2、規范性引用文件下列文中的條款通過本標準的引用而成為本標準的條款。凡是注日期的引用文件，其隨后所有的修改(不包括勘誤的內容)或修訂版均不適用于本標準，凡是不注日期的引用文件，其最新版本適用于本標準。JT/T4一凡是不注日期的引用文件，其最新版本適用于本標準。JT/T4一2004公路橋梁板式橡膠支座JTGD60一2004公路橋涵設計通用規范JTGD62一2004公路鋼筋混凝土及預應力混凝土橋涵設計規范3、支座要求3.1支座產品分類、代號、結構、技術要求、試驗方法、檢驗規則及標志、包裝、貯存、運輸、安裝和養護均應滿足JT/T4一2004的要求.3.2支座使用階段平均壓應力6C=10MPa(S<7時6C=8MPa)；橡膠硬度60(IRHD)時，其常溫下剪變模量G=I.OMpa。剪變模量隨溫度下降而遞增，當累年最冷月平均溫度的平均值O~-10°C時為寒冷地區，G=1.2MPa；當?shù)陀?10°C時為嚴寒地區，G=1.5MPa；當?shù)陀?25C時，G=2.0MPa。全國氣溫分區圖見JTGD60一2004附錄B。3.3支座橡膠彈性體體積模量Eb=2000MPa。支座與混凝土接觸時，摩擦系數p=0.3，與鋼板接觸時，摩擦系數p=0.2。聚四氟乙烯板與不銹鋼板接觸(加硅脂)時，pf=0.06，當溫度低于-25C時，pf值增大30%，當不加硅脂時，pf應加倍。若有實測資料時，也可按實測資料采用。3.4橡膠支座剪切角a正切值，當不計制動力時，tana不大于0.5，當計入制動力時，tana不大于0.7.3.5橡膠支座的計算和驗算均應滿足JTGD62一2004的要求。4、普通板式橡膠支座4.1普通板式橡膠支座結構示意圖見圖1、圖2。4.2普通板式橡膠支座代號，矩形為GJZ、圓形為GYZ。其規格系列見表1,表中符號意義如下:iaxib或d——平面尺寸或直徑；Rck——最大承壓力；S-----形狀系數；t-----支座總厚度；△i1,-----不計制動力時最大位移量；△i2-----計人制動力時最大位移量；te-----橡膠層總厚度；tan6——允許轉角正切值；RGk—抗滑最小承壓力；板式橡膠支座產品代號表示方法

檬膠種類：天然橡膠CK氯丁橡膠舛隊三元乙丙椽膠EPD舊夕卜形尺寸(矩形La!Lb11C(Tim)回吟eft(mm))形式代號【F4素示四氧滑板支叵無代號為晉通支國形式代號【F4素示四氧滑板支叵無代號為晉通支國GY2表不公路橋梁圓形支座fTBZ表示鐵路橋梁板式支座：TCYB表示公路球起式支座?做拼方向1-間花MFii:-株獨完； 一「口間四:股￡耳哈,L--盾魅翻娘嚀腹一GJZ、GYZ板式橡膠支座規格系列選用參數laxlb(或d)rcktan0(0的單位為rad)Rck(KN)t1t0序(mm)(KN)St(mm)△l1△l2te溫?zé)岬貐^(qū)寒冷地區嚴寒地區溫?zé)岬貐^(qū)寒冷地區嚴寒地區(mm(mmGJZ2157150.0100.0090.0071100x1501015.48287.510.5200.0160.0130.01135(53)42(63)53(79)52GJZ2157150.0080.0070.0062100x2001376.11287.510.5200.0130.0110.00947(70)56(84)70(105)522157150.0050.005-287.510.5200.0080.0070.0063GYZd1501547351014250.0110.0090.00841(62)49(74)62(930524212.17.5300.0140.0120.0102157150.0050.005-4GJZ150x150196728357.51010.51420250.0080.0110.0070.0090.0060.00853(79)63(95)79(118)524212.17.5300.0140.0120.010

53215GJZ266150x2008.062157150.005--70(105)84(126)105(158)52287.510.50.006200.0050.0053510140.008250.0070.0064212.17.50.011300.0090.0086GJZ336150x2508.84287.510.50.005200.005-88(131)105(158)131(197)523510140.007250.0060.0054212.17.50.009300.0080.0067GJZ406150x3009.44287.510.50.005200.005-105(1580126(189)158(236)523510140.006250.0060.0054212.17.50.008300.0080.0068GYZd2002849.53510140.00525--73(110)88(132)110(165)524212.17.50.006300.0050.0054915210.007350.0060.0055617.24.5400.0080.0070.006

5975351014250.005--GJZ4212.17.5300.0060.0050.0059200x2003619.5491521350.0070.0060.00593(140)112(168)140(210)525617.24.5400.0080.0070.0064212.17.5300.0050.005-:GJZ200x25045610.6491521350.0060.0050.005117(175)140(210)175(263)525617.24.5400.0070.0060.00530811.2210.0060.0050.0051GJZ200x3005517.17411216.8290.0090.0080.007140(210)168(252)210(315)83521622.4370.0130.0110.00930811.2210.0050.005-:GJZ200x3506467.62411216.8290.0080.0070.006163(245)196(294)245(368)83521622.4370.0110.0100.008

:GJZ741200x4007.98304111.216.80.005210.008290.0050.0070.005187(280)224(336)280(420)83521622.40.010370.0090.007:GYZd250452GJZ576250x250GJZ696250x3007.57.58.214152121616.822.40.007290.009370.0060.0080.0050.006115(172)146(219)175(263)137(206)175(263)210(315)172(258)219(328)263(394)836374415263744152632024121620241216202833.616.822.42833.616.822.4280.012450.014530.007290.009370.012450.014530.006290.00837450.0140.0100.0120.0060.0080.0100.0120.0050.0070.0080.0080.0100.0050.0060.0080.0100.0050.0060.007

195742433.60.012530.0100.0091GJZ816250x3508.79411216.80.005290.005-204(306)245(368)306(459)83521622.40.007370.0060.0056320280.009450.0080.006742433.60.011530.0090.008:GJZ936250x400GJZ1056250x4509.299.71411216.80.00529--233(350)263(394)280(420)315(473)350(525)394(591)83521622.40.006370.0050.0056320280.008450.0070.0067441241233.616.80.01053290.0050.0080.007521622.40.006370.0050.0056320280.007450.0060.006742433.60.009530.0080.0072GJZ 117610.0411216.8290.005--292(438)350(525)438(656)83

0250x50075263162022.428370.0060.007450.0050.0060.005742433.60.008530.0070.0062GYZd300661GJZ841300x300GJZ986300x3509.069.069.785263162022.4280.005370.007450.0050.0060.005165(247)210(315)245(368)198(297)252(378)294(441)247(371)315(473)368(551)8374855263748552637424281620242816202433.639.222.42833.639.222.42833.60.008530.010610.005370.007450.008530.010610.005370.00645530.0070.0070.0080.0050.0060.0070.0080.0050.0050.0060.0060.0070.0050.0060.0070.0050.005

887852839.20.009610.0070.0062GJZ1131300x40010.4521622.4370.005--280(420)336(504)420(630)836320280.005450.005-742433.60.007530.0060.003852839.20.008610.0070.0062GJZ1276300x45010.96320280.005450.005-315(473)378(5670473(709)83742433.60.006530.0050.005852839.20.007610.0060.0052GJZ1421300x5008.285416.23.1380.0070.0060.005350(525)420(630)525(788)114692230.80.009490.0080.0068427.38.50.011600.0100.0082GJZ1566300x5508.585416.23.10.006380.0050.005385(578)462(693)578(866)114692230.80.008490.0070.0068427.38.5600.0110.0090.008

5542GJZ1711300x6008.645416.23.10.006380.0050.005420(630)504(756)630(945)114692230.80.008490.0070.0068427.38.50.010600.0090.0072GYZd35090810.6632028450.005--224(337)269(404)337(505)83742433.60.005530.005-852839.20.006610.0060.005963244.80.007690.0060.0053GJZ1156350x35010.6632028450.005--286(429)343(515)429(643)83742433.60.005530.005-852839.20.006610.0060.005963244.80.007690.0060.0053GJZ1326350x4008.265416.23.10.006380.005-327(490)392(588)490(735)114692230.80.008490.0060.0058427.38.50.010600.0080.007

5350x6005692230.80.006490.0050.0058427.38.50.007600.0060.005993346.20.0090.0070.0063GYZd40011958.865416.23.1380.005--293(440)352(528)440(660)114692230.80.006490.0050.0058427.38.50.007600.0060.005993346.20.0090.0080.0063GJZ1521400x400GJZ1716400x4508.869.45416.23.1380.005--373(560)420(630)448(672)504(756)560(840)630(945)11469842227.30.838.50.006490.007600.0050.0060.0050.005996984332227.46.230.838.50.0090.005490.007600.0080.0050.0060.0060.005

991143338.46.253.90.008820.010.0070.0080.0060.0073GJZ1911400x500GJZ2106400x5509.8710.2692230.80.005490.005-467(700)513(770)560(840)616(924)700(1050)770(1156)114849927.3338.546.20.006600.0070.0050.0060.0050.0051146938.:53.930.80.00982490.0050.0080.0068427.38.50.006600.0050.005993346.20.0070.0060.0064GJZ2301400x60010.6692230.8490.005--560(840)672(1008)840(1260)1148427.38.50.005600.005-993346.2710.0070.0060.0054GJZ2490400x65011.0692230.8490.005--607(910)728(1092)910(1365)1148427.38.50.005600.005-993346.20.0060.0050.005

4GYZd450152110692230.8490.005--371(557)445(668)557(835)1148427.38.50.005600.005-993346.20.0060.0060.00511438.53.9820.0080.0070.0054GJZ1936450x45010692230.8490.005--473(709)567(851)709(1063)1148427.38.50.005600.005-993346.20.0060.0060.00511438.53.9820.0080.0070.0054GJZ2156450x50010.58427.38.50.005600.005-525(788)630(945)788(1299)114993346.20.0060.0050.00511438.53.90.007820.0060.0054GJZ2376450x55011.08427.38.5600.005--578(866)693(1040)866(1299)114993346.20.0050.005-11438.53.90.006820.0060.0054GJZ 25968.47022.31.5500.0060.0050.005630(945)756(1134)945(1418)155

7450x6005249030420.008650.0070.00611037.52.50.010800.0090.0074GJZ2816450x6508.697022.31.50.005500.005-683(1024)819(1229)51559030420.007650.0060.00511037.52.50.009800.0080.0074GYZd5001886GJZ2401500x5008.178.177022.31.50.005500.005-458(687)583(875)550(825)700(1050)687(1031)875(1313)151559030420.007650.0060.00511037.52.50.009800.0080.007130704522.6331.50.011950.005500.0100.0050.008901101303037.454252.5630.007650.009800.011950.0060.0080.0100.0050.0070.008

22.0.0057031.5500.005-540.0070.0060.005903042655GJZ33226468.56642(963)770(1155)963(1444)1551500x55037.0.0090.0070.00611052.58051860.0100.0090.00713045639594922.0.0057031.550--510.0060.005903042650.0055GJZ891050(157528918.92700(1050)840(1269)1552500x60037.0.0080.0070.006)11052.58055320.0100.0080.00713045639528722.7031.5500.005--50.0060.005903042650.0055GJZ451138(170631369.25758(1138)910(1365)1553500x65037.0.0060.005)11052.5800.0085980.0090.0081304563950.0076322.5GJZ7031.5500.005--1225(183833819.555817(1225)980(1470)1554500x700)903042650.0060.005-

1311037.52.50.007800.0060.00513045630.009950.0070.0065GYZd550229099030420.006650.005-554(832)665(998)832(1247)15511037.52.50.007800.0060.00513045630.009950.0070.00615052.73.5110.0100 60.0090.0075GJZ2916550x55099030420.006650.005-706(1059)847(1271)515511037.52.50.007800.0060.0051301504552.6373.50.00995110.：。0 60.0070.0090.0060.0075GJZ3186550x6009.4901101303037.454252.5630.005650.007800.008950.0050.0060.0070.0050.006770(1155)924(1386)5155

15052.73.5110.0100.0080.007903042650.0050.005-5GJZ11037.52.5800.0060.0050.0051001(15021251(18778550x65034569.761304563950.0080.0060.005834(1251)))15515052.73.5110.0090.0080.006903042650.005--11037.52.5800.0060.005-5GYZd60027349.831304563950.0070.0060.005660(990)792(1188)990(1484)15515052.73.5110.0080.0070.006903042650.005--11037.52.5800.0060.005-6GJZ600x60034819.831304563950.0070.0060.005840(1260)5515515052.73.5110.0080.0070.006903042650.005--6GJZ600x650377610.211037.52.5800.0050.006-910(1365)55155

9115052.73.5110.0060 90.0060.0051706084120.0075 90.0060.0066GJZ4416650x7009.21023650.4770.0060.005-55518512545630.007950.0060.0051485475.6110.0083 90.0070.0061716388.2130.0101 40.0090.0076GJZ4736650x7509.531023650.40.0050.005-551851254563950.0070.0060.005148171546375.688.2110.0083 4130.0091 90.0070.0080.0050.0066GYZd70037399.5810212514836455450.46375.60.0050.00695110.〉3 80.0050.0050.0060.0050.005898(1347)55185注1:抗滑最小承載力攔中，括號外數字為支座與混凝土接觸時的采用值括號內數字為支座與鋼接觸時的采用值;其值均為不計汽車制動力的情況.當計入汽注2:允許轉角正切值是沿支座短邊方向轉動時計算值若沿長邊方向轉動應自行計算.gyzf4、gjzf4四氟滑板式橡膠支座規格系列選用參數序WbRckSt(mm)(mm)tetan。（的單位為rad）Rgk(KN)t1 t°tf(或d)(mm順橋向橫橋向順橋向橫橋向(mrm溫?zé)岷鋰?yán)寒溫?zé)岷鋰?yán)寒(mm)(KN地區地區地區地區地區地區(mm(mm) )(mm1GJZF4100x1501015.4823±2±30±15°;。0.0090.0075363795 2230±30200.01600.0130.0112一1376.1123±2±30±150.00870.0070.0067°841055 2230±30200.01310.0110.0093GYZF4d150154723±2±30:150.0057022:200.00850.0070.00637±30250.01140.0090.00844300.01430.0120.0104gjzf40150x15196723±2±303150.005702230±30200.00850.0070.006

9一3619.55837±30±2±30:40250.00890.00510.0070.0061401682105 2244300.00640.0050.00551350.00770.0060.00558400.00890.0070.006:—45610.644±30±2±30:300.00540.005-1752102635 2251350.00640.0050.00558400.00750.0060.0051GJZF4200x3005517.1732±30±2±30:210.00660.0050.0052102523158 3243290.00980.0080.00754370.01310.0110.009:—6467.6232±30±2±30:210.00590.005-2452943688 3243290.00890.0070.00654370.01180.0100.0081GJZF4200x407417.9832±30±2±30±210.00550.005-2803364208 32

176530.00710.0060.00587610.00830.0070.0062?！?27610.965±70±3±70;450.00550.005-47356